RESUMO

The debranning process, at an industrial scale, was applied to grains of two wheat cultivars to determine its effect on Fusarium mycotoxin content and antioxidant activity. Grain samples from the BRS Marcante and BRS Reponte wheat cultivars, naturally contaminated by Fusarium, were used in the study. The dry wheat samples were processed on the polisher once or twice and evaluated by hardness index, chemical composition (moisture, protein, and ash), deoxynivalenol (DON) and zearalenone (ZON) levels, phenolic content, and antioxidant activity. In the BRS Marcante cultivar, the debranning process only slightly reduced the DON and ZON contents in whole-wheat flours compared with the previous cleaning treatment (no-debranned). In the BRS Reponte cultivar, the DON concentration decreased by 36% at a debranning ratio of 5%, obtained by polishing, compared with prior cleaning treatment (no-debranned). In addition, the polishing reduced the ZON level by 56% compared with the cleaned wheat. The debranning process did not reduce the antioxidant capacity. Therefore, debranning is a suitable technology to obtain safer and healthier food by minimizing the mycotoxin content and retaining antioxidant capacity.

Assuntos

RESUMO

Fusarium graminearum causes destructive ear rot diseases in maize and wheat. New antifungals are essential to combat this pathogen, and aerial parts of Justicia species (Acanthaceae) are a potential source. We investigated the antifungal activity of extracts from stems and leaves of five Justicia species native to Northwest Argentina. The aerial parts were subjected to sequential extractions with dichloromethane, ethyl acetate, and methanol. The resulting extracts were tested by the disc diffusion method against F. graminearum strains. Only the leaf and stem extracts from J. xylosteoides displayed inhibitory effects, with the dichloromethane leaf extract as the most active. The compounds involved were identified as the lignans hinokinin, savinin, and isohibalactone. Both the dichloromethane extract and hinokinin synergised with tebuconazole, and inhibited deoxynivalenol biosynthesis. The identified compounds warrant further research as additives to azole fungicides for F. graminearum control.

RESUMO

Fusarium cerealis is a causal agent of Fusarium Head Blight in wheat, and it produces both deoxynivalenol (DON) and nivalenol (NIV). Nevertheless, the effect of environmental factors on the growth and mycotoxin production of this species has not been studied so far. The objective of this study was to investigate the impact of environmental factors on the growth and mycotoxin production of F. cerealis strains. All strains were able to grow in a wide range of water activity (aW) and temperatures, but their mycotoxin production was influenced by strain and environmental factors. NIV was produced at high aW and temperatures, while optimal conditions for DON production were observed at low aW. Interestingly, some strains were able to simultaneously produce both toxins, which could pose a more significant risk for grain contamination.

RESUMO

Mycotoxins are toxic secondary metabolites produced by a variety of fungi, which when ingested can cause several deleterious effects to the health of humans and animals. In this work, the detection and quantification of six major mycotoxins (aflatoxins-AFLA, deoxynivalenol-DON, fumonisins-FUMO, ochratoxin A-OTA, T-2 toxin-T-2 and zearalenone-ZON) in 1749 samples of feed and feed ingredients for cattle, collected in Brazil between 2017 and 2021, was carried out using enzyme-linked immunosorbent assay (ELISA). In total, 97% of samples were contaminated with at least one mycotoxin, yet, very few samples exceeded the lowest European Union guidance values for cattle, and the estimated daily intake also showed a low risk for the animals. However, co-occurrences were widely observed, as 87% of samples contained two or more mycotoxins at the same time, and the presence of more than one mycotoxin at the same time in feed can lead to interactions. In conclusion, the contamination of feed and feed ingredients for cattle with mycotoxins in Brazil is very common. Hence, the monitoring of these mycotoxins is of significant importance for food safety.

Assuntos

RESUMO

Fusarium graminearum sensu stricto is, worldwide, the main causal agent of Fusarium head blight in small cereal crops such as wheat, barley, and oat. The pathogen causes not only reductions in yield and grain quality but also contamination with type-B trichothecenes such as deoxynivalenol. Prevention strategies include the use of less susceptible cultivars through breeding programs, cultural practices, crop rotation, fungicide application, or a combination of them through an integrated pest management. Additionally, the use of more eco-friendly strategies by the evaluation of microorganisms and natural products is increasing. The effect of combining Bacillus velezensis RC218 and chitosan on Fusarium Head Blight (FHB) and deoxynivalenol accumulation under greenhouse and field conditions in bread and durum wheat was evaluated. Under greenhouse conditions, both B. velezensis RC218 and chitosan (0.1%) demonstrated FHB control, diminishing the severity by 38 and 27%, respectively, while the combined treatment resulted in an increased reduction of 54% on bread wheat. Field trials on bread wheat showed a biocontrol reduction in FHB by 18 to 53%, and chitosan was effective only during the first year (48% reduction); surprisingly, the combination of these active principles allowed the control of FHB disease severity by 39 and 36.7% during the two harvest seasons evaluated (2017/18, 2018/19). On durum wheat, the combined treatment showed a 54.3% disease severity reduction. A reduction in DON accumulation in harvested grains was observed for either bacteria, chitosan, or their combination, with reductions of 50.3, 68, and 64.5%, respectively, versus the control.

Assuntos

RESUMO

Mycotoxins are unavoidable contaminants produced by fungi in food, especially grains. This study aimed to measure the occurrence and levels of total aflatoxins (AFs); ochratoxin A (OTA); zearalenone (ZEN); fumonisins B1, B2, and B3 (FUM); deoxynivalenol (DON); and T-2/HT-2 toxins in the four most commonly consumed breakfast cereals in Chile and to assess mycotoxin exposure and risk in children aged 2 to 13 years due to cereal consumption. In this study, a total of 110 batches with three subsamples of the four brands were sampled in supermarkets from November 2019 to June 2021. Samples were analyzed by Veratox® ELISA (Neogen). Exposure was assessed by estimated daily intake (EDI) considering the levels found in a modified lower bound (mLB) and upper bound (UB). Risk was estimated by margin of exposure (MOE) in the case of OTA and AFs and hazard quotient (HQ) for the rest of the mycotoxins. No T2/HT2 toxins were detected. Few samples had quantifiable levels of ZEN, FUM, and DON except for brand 1, with a mean (standard deviation, SD) of 54 (20), 1552 (351), and 706 (218) ng/g, respectively. In addition, three FUM samples and one DON sample had values over the Chilean regulation. Brands 2, 3, and 4 had quantifiable levels of AFs, with mean (SD) values of 1.3 (0.1), 2.1 (0.6), and 1.9 (0.4) ng/g, respectively. Brand 3 had quantifiable levels of OTA, with a mean (SD) of 2.3 (0.4) ng/g. Estimated exposure indicated a risk of AFs in all scenarios, and of FUM for brand 1 consumption, OTA and DON for brand 3 consumption, and OTA for brand 4 consumption in the mLB worst-case scenario. In general, mycotoxin levels were below the Chilean regulatory limits, but most of them were above the EU regulation for processed cereal-based food in young children. Because the risk was higher in the 2- to 5-year-old children, we recommend special regulations for this group in Chile.

Assuntos

RESUMO

The influence of aw on DON and its acetyl derivatives biosynthesis by a strain of Fusarium graminearum s.s. (ITEM 4606) which produces DON, 3-ADON and 15-ADON was evaluated. Trichothecene production was studied on agar wheat 2% at 0.95 and 0.99 aw at different temperatures (10, 15, 20, 25 and 30 °C) and incubation times (7, 14, 21 and 28 days). Statistical analysis (ANOVA) showed that aw, temperature, incubation time and their interactions were significant on the production of DON, 3-ADON and 15-ADON (p < 0.0001). The pattern of toxin production was influenced by aw, showing differences for the three toxins. The maximum accumulation of DON occurred at 30 °C at 0.99 aw (14 d) and at 25 °C at 0.95 aw (7 and 21 d). The highest concentration of 3-ADON at 0.95 aw was observed at 25 °C and 7 days, and it was significantly higher than all the other values registered. At 0.99 aw, the maximum occurred at 30 °C and 21 days, but another significantly high accumulation was observed at 28 days at the same temperature. For 15-ADON, at 0.95 aw, the highest amount of toxin was accumulated at 10 °C, both at 7 and 28 days. At 0.99 aw, a maximum was observed at 10 °C and 7 days, significantly different from the values observed at the other conditions. The toxin accumulated at a higher concentration at 0.95 aw was 15-ADON (173.2 µg/g) and at 0.99 aw, 3-ADON (370.6 µg/g). A marked influence of aw on the maximum toxin accumulation with respect to temperature and time was observed for trichothecene production. This is an important fact to consider when designing predictive models to prevent toxin contamination, both in the field and during storage, especially in intermediate drying stages.

Assuntos

RESUMO

Deoxynivalenol (DON) and arsenic (As) are widespread environmental contaminants, which are frequently found in human and animal food products. The intestine is a common target of As and DON when they are digested. Numerous studies mainly evaluate the individual effects whereas their combined toxicity has rarely been elucidated. Hence, this study was to assess the effect of low dose of NaAsO2 on DON-induced intestinal damage and explore the underling mechanism in mice and IPEC-J2 cells. The results showed that low dose of NaAsO2 exacerbated DON-induced intestinal impairment by increasing intestinal permeability and decreasing the abundance of tight junction proteins (ZO-1, Occludin, Claudin-1). Further, low dose of NaAsO2 enhanced the AhR signaling pathway and autophagy-related mRNA/protein expressions induced by DON. Interestingly, FICZ, an AhR activator, instead of CH223191, an AhR inhibitor, could alleviate toxicity of the low dose of NaAsO2 in the mice and IPEC-J2 cells. Compared to the WT IPEC-J2 cells, the intestinal barrier damage was more serious in LC3B-/- IPEC-J2 cells induced by low dose of NaAsO2 combination with DON. Collectively, our study demonstrated that low dose of NaAsO2 exacerbated DON-induced intestinal barrier impairment in vivo and in vitro. The present study also demonstrated that activation of AhR-mediated autophagy might be a self-protection mechanism. Hence, AhR and autophagy might be novel therapeutic targets to prevent or alleviate NaAsO2 combined with DON-induced intestinal barrier impairment.

Assuntos

RESUMO

Deoxynivalenol (DON) is a toxic secondary metabolite produced by fungi that contaminates many crops, mainly wheat, maize, and barley. It affects animal health, causing intestinal barrier impairment and immunostimulatory effect in low doses and emesis, reduction in feed conversion rate, and immunosuppression in high doses. As it is very hard to completely avoid DON's production in the field, mitigatory methods have been developed. Biodegradation has become a promising method as new microorganisms are studied and new enzymatic routes are described. Understanding the common root of bacteria with DON degradation capability and the relationship with their place of isolation may bring insights for more effective ways to find DON-degrading microorganisms. The purpose of this review is to bring an overview of the occurrence, regulation, metabolism, and toxicology of DON as addressed in recent publications focusing on animal production, as well as to explore the enzymatic routes described for DON's degradation by microorganisms and the phylogenetic relationship among them.

Assuntos

RESUMO

This study aimed to evaluate the antimycotoxigenic effect of essential oils (EOs) obtained from four different aromatic plants on the production of deoxynivalenol (DON) and zearalenone (ZEA) by Fusarium graminearum. The EOs from ginger (GEO), turmeric (TEO), thyme (ThEO) and rosemary (REO) were obtained by hydrodistillation and identified by gas chromatography/mass spectrometry (GC/MS). The major compounds found were mostly monoterpenes and sesquiterpenes. The minimum inhibitory concentration (MIC) and minimum fungicide concentration (MFC) were 11.25, 364, 366 and 11,580 µg mL-1 for ThEO, GEO, REO and TEO, respectively. The results evidenced that the assessed EOs inhibited DON and partially ZEA production by F. graminearum. ThEO and GEO were the EOs with most potent antimycotoxigenic action for DON and ZEA, respectively. These EOs have shown promising results in vitro regarding inhibition of mycotoxin production and might be used in the future as substitutes for synthetic fungicides.

Assuntos

RESUMO

The current study investigated the fungal diversity in freshly harvested oat samples from the two largest production regions in Brazil, Paraná (PR) and Rio Grande do Sul (RS), focusing primarily on the Fusarium genus and the presence of type B trichothecenes. The majority of the isolates belonged to the Fusarium sambucinum species complex, and were identified as F. graminearum sensu stricto (s.s.), F. meridionale, and F. poae. In the RS region, F. poae was the most frequent fungus, while F. graminearum s.s. was the most frequent in the PR region. The F. graminearum s.s. isolates were 15-ADON genotype, while F. meridionale and F. poae were NIV genotype. Mycotoxin analysis revealed that 92% and 100% of the samples from PR and RS were contaminated with type B trichothecenes, respectively. Oat grains from PR were predominantly contaminated with DON, whereas NIV was predominant in oats from RS. Twenty-four percent of the samples were contaminated with DON at levels higher than Brazilian regulations. Co-contamination of DON, its derivatives, and NIV was observed in 84% and 57.7% of the samples from PR and RS, respectively. The results provide new information on Fusarium contamination in Brazilian oats, highlighting the importance of further studies on mycotoxins.

Assuntos

RESUMO

Aflatoxin B1 (AFB1), ochratoxin A (OTA), zearalenone (ZEN), and deoxynivalenol (DON) are frequent mycotoxins that may cause carcinogenic, mutagenic, estrogenic, or gastrointestinal effects. The aim of this study was to assess the exposure to and risk from AFB1, OTA, ZEN, and DON in 172 participants of the Maule Cohort (MAUCO) by a biomarker analysis in urine and to associate their exposure with food consumption and occupation. Mycotoxins in the first morning urine were analyzed by solid-phase extraction and quantified by Ultra-High-Performance Liquid Chromatography with a mass-mass detector. Participants' information regarding food consumption, occupation, and other characteristics was obtained from a baseline and 2-year follow-up survey of the cohort. The prevalence and mean levels of mycotoxins in the urine were as follows: DON 63%, 60.7 (±78.7) ng/mL; AFB1 8%, 0.3 (±0.3) ng/mL; α-zearalenol (α-ZEL) 4.1%, 41.8 (±115) ng/mL; ß-ZEL 3.5%, 17.4 (±16.1) ng/mL; AFM1 2%, 1.8 (±1.0) ng/mL; OTA 0.6% (1/172), 1.3 ng/mL; and ZEN 0.6%, 1.1 ng/mL. These results were translated into exposures of DON, ZEN, and aflatoxins of public health concern. Participants who consumed coffee and pepper the day before had a significantly greater presence of DON (OR: 2.3, CI95 1.17-4.96) and total ZEL (OR: 14.7, CI95 3.1-81.0), respectively, in their urine. Additionally, we observed associations between the habitual consumption of beer and DON (OR: 2.89, CI95 1.39-6.42). Regarding the levels of mycotoxins and the amount of food consumed, we found correlations between DON and nuts (p = 0.003), total ZEL and cereals (p = 0.01), and aflatoxins with capsicum powder (p = 0.03) and walnuts (p = 0.03). Occupation did not show an association with the presence of mycotoxins in urine.

Assuntos

RESUMO

The goal of this survey was to evaluate the presence and concentration as well as the co-occurrence of legislated and non-legislated mycotoxins in wheat flour samples from Brazil. A total of 200 wheat flour samples were analysed by a validated multi-mycotoxins method. DON was the mycotoxin with the highest occurrence, being present in 100% of the analysed samples and showing contamination in both years and regions (53-2905 µg kg-1). ZEN was detected in 51% (

Assuntos

RESUMO

We assessed the mycobiota diversity and mycotoxin levels present in wild rice (Oryza latifolia) from the Pantanal region of Brazil; fundamental aspects of which are severely understudied as an edible plant from a natural ecosystem. We found multiple fungal species contaminating the rice samples; the most frequent genera being Fusarium, Nigrospora and Cladosporium (35.9%, 26.1% and 15%, respectively). Within the Fusarium genus, the wild rice samples were mostly contaminated by the Fusarium incarnatum-equiseti species complex (FIESC) (80%) along with Fusarium fujikuroi species complex (20%). Phylogenetic analysis supported multiple FIESC species and gave support to the presence of two putative new groups within the complex (LN1 and LN2). Deoxynivalenol (DON) and zearalenone (ZEN) chemical analysis showed that most of the isolates were DON/ZEN producers and some were defined as high ZEN producers, displaying abundant ZEN levels over DON (over 19 times more). Suggesting that ZEN likely has a key adaptive role for FIESC in wild rice (O. latifolia). Mycotoxin determination in the rice samples revealed high frequency of ZEN, and 85% of rice samples had levels >100 µg/kg; the recommended limit set by regulatory agencies. DON was only detected in 5.2% of the samples. Our data shows that FIESC species are the main source of ZEN contamination in wild rice and the excessive levels of ZEN found in the rice samples raises considerable safety concerns regarding wild rice consumption by humans and animals.

Assuntos

RESUMO

Fusarium Head Blight (FHB) is a very important fungal disease that affects small grain cereals worldwide. This disease not only causes yield loses but also crops contamination with mycotoxins such as deoxynivalenol (DON) and nivalenol (NIV). Species within the Fusarium graminearum species complex have been described as the main causal agents of this disease, however lately there have been few reports of Fusarium cerealis causing the disease in wheat and barley in different parts of the world. This study evaluated the aggressiveness of F. cerealis to durum wheat cultivars and also mycotoxin production in planta. Moreover, the mycotoxin profile of F. cerealis strains was characterized molecularly and chemically. All durum wheat cultivars showed typical FHB symptoms but the disease severity varied among them in levels up to 66%. In addition, seventeen different compounds were detected in the infected heads including DON, NIV and nivalenol-3-ß-d-glucose (NIV3G). NIV was detected in all cultivars and was the most produced mycotoxin with levels ranging from 1.04 to 6.8 mg/kg. On the other hand, the molecular analysis of F. cerealis strains showed that all of them possessed NIV genotype while the chemical assessment showed that the strains were able to produce not only this toxin in vitro but also DON, zearalenone and other twenty-one secondary metabolites. The increasing incidence of F. cerealis and the possible contamination of crops with the mycotoxins that it produces are of great concern for food security and world cereal trade since it has been reported that NIV is more toxic for humans and animals than DON.

Assuntos

RESUMO

Wheat is one of the most important crops in Argentina and worldwide. One of the major diseases affecting the crop is the Fusarium Head Blight (FHB). It is an endemic disease caused mainly by Fusarium graminearum, the most common agent of FHB around the world. The infection is strongly influenced by environmental parameters and occurs mostly when there are favourable conditions of moisture and temperature during wheat anthesis or flowering. This destructive disease affects wheat, barley and other small grains and has the capability of destroying crops, causing great economic losses due to reduced grain quality, and the accumulation of significant levels of mycotoxins such as trichothecenes. The aim of this study was to evaluate the influence of temperature on mycotoxin biosynthesis, on three strains of F. graminearum of 15-ADON genotype and one of 3-ADON genotype, with different capacity of synthesizing DON, 3-ADON and 15-ADON. Trichothecene production of the strains at different temperatures (5, 10, 15, 20, 25, 30 and 35 °C) was evaluated after 7, 14, 21, 28 and 35 d of incubation. The optimum temperature to produce DON and 3-ADON was between 25 and 30 °C, but the maximum production of 15-ADON occurred at a lower temperature (10 °C) for all the strains. Conversely, the minimum production of DON and 3-ADON was recorded between 5 and 10 °C and of 15-ADON between 30 and 35 °C. A possible explanation for the similar accumulation of both acetyl derivatives by strains of different chemotype and genotypes could be that the acetyl derivatives biosynthesis is regulated by temperature.

Assuntos

RESUMO

Fusarium head blight (FHB) is a devastating disease in wheat. The use of resistant germplasm from diverse sources can significantly improve resistance to the disease. "Surpresa" is a Brazilian spring wheat cultivar with moderate FHB resistance, different from currently used sources. In this study, we aimed to identify and map the genetic loci for FHB resistance in Surpresa. A mapping population consisting of 187 recombinant inbred lines (RILs) was developed from a cross between Surpresa and a susceptible spring wheat cultivar, "Wheaton." The population was evaluated for FHB by the point-inoculation method in three greenhouse experiments and four field trials between 2016 and 2018. Mean disease severity for Surpresa and Wheaton was 41.2 and 84.9% across the 3 years of experiments, ranging from 30.3 to 59.1% and 74.3 to 91.4%, respectively. The mean FHB severity of the NILs was 57%, with an overall range from 7 to 100%, suggesting transgressive segregation in the population. The population was genotyped using a two-enzyme genotyping-by-sequencing approach, and a genetic map was constructed with 5,431 single nucleotide polymorphism (SNP) markers. Four QTL for type II resistance were detected on chromosomes 3A, 5A, 6A, and 7A, explaining 10.4-14.4% of the total phenotypic variation. The largest effect QTL was mapped on chromosome 7A and explained 14.4% of the phenotypic variation; however, it co-localized with a QTL governing the days to anthesis trait. A QTL for mycotoxin accumulation was also detected on chromosome 1B, explaining 18.8% of the total phenotypic variation. The QTL for FHB resistance identified in the study may diversify the FHB resistance gene pool and increase overall resistance to the disease in wheat.

RESUMO

Fumonisins (FB1+FB2) and deoxynivalenol (DON) are mycotoxins produced by Fusarium species that might be present in maize and maize products. Knowledge on their occurrence in nixtamalized maize from Mexico together with an accompanying risk assessment are scarce, while nixtamalized maize is an important food in Mexico. This study presents the occurrence of FB1 + FB2 and DON in nixtamalized maize samples collected in Mexico City and analyses their distribution and resulting estimated daily intake for Mexican consumers by a probabilistic approach using a two-dimensional Monte-Carlo simulation. The results obtained reveal that for FB1 + FB2, 47% of the Mexican men and 30% of the Mexican women might exceed the provisional tolerable daily intake (PMTDI) of 2 µg/kg bw/day for fumonisins and for DON, 9% of men and 5% of women would be exceeding the PMTDI of 1 µg/kg bw/day, corresponding to the high consumers. The results raise a flag for risk managers in Mexico, to consider regulations and interventions that lower mycotoxin levels in nixtamalized maize for human consumption.

Assuntos

RESUMO

Mycotoxins are toxic secondary metabolites produced by fungus which cause worldwide concern regarding food and feed safety. Ochratoxin A (OTA), fumonisin B1 (FB1) and deoxynivalenol (DON) are some of the main mycotoxins and oxidative stress is the main mechanism of toxicity. Thereby, this study investigates the in vitro cytoprotective effects of curcumin (CUR) and silymarin (SIL) - known for their strong antioxidant activity - in PK-15 cells exposed to OTA, FB1 and DON. Pretreatment with CUR and SIL enhanced the viability of cells exposed to the mycotoxins (P < 0.001) and attenuated reactive oxygen species (ROS) formation by DON (P < 0.01), partially reduced ROS formation by FB1 (P < 0.001), but not OTA. CUR significantly decreased apoptosis in cells exposed to DON (P < 0.01) but was not able to prevent apoptosis in cells exposed to OTA and FB1. Whereas SIL was able to prevent apoptosis in PK-15 cells exposed to FB1 and DON (P < 0.01) but was not able to decrease apoptosis in cells exposed to OTA. In summary, these data indicate that curcumin and silymarin are able to provide cytoprotection against toxicity induced by OTA, FB1 and DON in PK-15 cells.

Assuntos

RESUMO

The effects of mycotoxins on the productive performance of growing pigs and broilers were evaluated using meta-analytical approach. Two databases were constructed: (1) Broilers, with information collected from 51,497 birds and published in 158 scientific papers from 1980 to 2016; and (2) Pigs, with information collected from 7,743 animals and published in 72 scientific papers from 1980 to 2015. The meta-analyses were performed independently for each specie, following three sequential analyses: graphical, correlation, and variance-covariance. Broilers and pigs challenged by mycotoxins reduced (p < 0.05) feed intake by 9 and 6 %, weight gain by 15 and 11 %, and feed efficiency by 6 and 4 % compared with non-challenged animals, respectively. Aflatoxins were the most studied mycotoxins in both databases. Birds and pigs challenged by aflatoxins reduced (p < 0.05) feed intake by 10 and 8 %, growth by 15 and 11 %, and feed efficiency by 6 and 7 % compared to non-challenged animals, respectively. In both databases, variation on growth performance due to mycotoxins showed a linear relationship (p < 0.05) with the feed intake variation caused by the challenge. The intercepts of the regression-based equations were different from zero and negative, which may indicate that mycotoxins altered the maintenance requirements in challenged animals. In conclusion, both broilers and growing pigs show losses in performance responses and worse nutritional efficiency when challenged by mycotoxins.

Assuntos