RESUMO

Mushrooms are capable of bioconverting organic residues into food. Understanding the relationship between high-quality yields and substrate biomass from these residues is critical for mushroom farms when choosing new strains. The objective of this exploratory study was, therefore, to analyze whether exotic mushrooms, namely, Pleurotus eryngii, Flammulina velutipes, and Agrocybe aegerita, could biologically convert the substrate into edible mushrooms as effectively as Lentinula edodes (baseline). Five experiments were carried out. Biological efficiency, biodegradability coefficient, mass balance and chemical characterization of the substrate were evaluated. Strategically hydrating the sawdust enabled L. edodes to achieve the greatest biodegradability and biological efficiency of 0.5 and 94.2 kg dt-1, respectively. The values for L. edodes on wheat straw without hydration were 0.2 and 68.8 kg dt-1, respectively. From 1000 kg of fresh substrate, P. eryngii produced 150.1 kg of edible mushrooms, making it technically competitive with L. edodes on wheat straw (195.9 kg). Hence, P. eryngii was the most reliable option for scaling among the exotic mushrooms. The analytical insights from our study provide further knowledge to advance the field's prominence in high-throughput mushroom-producing systems, particularly for exotic mushrooms.

RESUMO

BACKGROUND: The fungus Agaricus subrufescens is grown commercially in China, the USA, Brazil, Taiwan and Japan, among others. However, each country adopts a cultivation system that significantly influences the agronomical parameters and chemical composition of the harvested mushrooms. In this study, the influence of the cultivation process on the content of ergosterol and vitamin D2 was evaluated. RESULTS: Four commercial strains of A. subrufescens (ABL 04/49, ABL CS7, ABL 18/01 and ABL 19/01) and two environmental cultivation conditions (in the field and a controlled chamber with the absence of sunlight) were used. Infield cultivation, ABL CS7 and ABL 19/01 strains presented better agronomic parameters, whereas in a protected environment ABL 19/01, ABL 04/49 and ABL 18/01 demonstrated better performance, respectively. The highest biological efficiency value (64%) was provided by ABL 19/01 strain in a controlled environment. CONCLUSION: The highest content in ergosterol (990 mg kg-1 ) and vitamin D2 (36.8 mg kg-1 ) were observed in mushrooms obtained in the field from strain ABL 04/49, which presents reasonable agronomic parameters for cultivation. © 2021 Society of Chemical Industry.

Assuntos

RESUMO

No in-depth investigation exists on the feasibility of integrating hydrothermal carbonization (HTC) and pelletization into the process of making spent mushroom substrate (SMS), an agro-food residue from the commercial mushroom industry, into an adsorbent for post-combustion CO2 removal. Therefore, this study analyzed if it could be possible for systematically converting low-pressure hydrochars of various SMSs into carbon-adsorbing mini-capsules. Sources of SMS included paddy straw and achiote capsule shell from Pleurotus ostreatus; eucalyptus sawdust and grassy straw from Lentinula edodes; and compost containing peat or soil as casing layer from Agaricus subrufescens. The eucalyptus sawdust and grassy straw from L. edodes outperformed the other biomaterials in adsorbing CO2, and thus effectively encapsuled most of the gas, 8.25 mmol g-1 and 8.10 mmol g-1, respectively. They contained mostly hetero-atoms of O and N, requiring less unit energy to bind acidic molecules of CO2 at the alkaline sites. The amount of unit energy the pore-filling process demanded at 25 °C was 12.65 kJ mol-1, an attribute of self-sustaining and saleable physisorption. A negative 6.80 kJ mol-1 free energy validated both spontaneity and exothermal of biocarbons at steady-state atmosphere. The major findings and innovations of our study support utilizing SMS as an adsorbent as a carbon capture, storage and utilization networking. Our insights into the physisorption-chemisorption on SMS are timely and relevant to help manage the re-use of SMS, and thus bring the global mushroom industry closer to environmental sustainability and toward a lower carbon society and circular economy.

Assuntos

RESUMO

The aim of the research was (i) to evaluate white and cream strains of A. bisporus yields when challenged or not with the pathogen L. fungicola, (ii) to identify the more aggressive pathogen isolates, and (iii) to develop a diagrammatic scale of spot symptoms on infected mushrooms. The experiment was carried out using two strains of A. bisporus (white and cream strains, ABI 19/01 and PB 19/01, respectively) and four isolates of L. fungicola (LF 19/01, FL 19/02, LF 19/03, and LF 19/04). The A. bisporus white strain (ABI 19/01) reached a higher yield of healthy mushrooms compared to the cream strain (PB 19/01) with values of 23.8 and 14.1%, respectively. The LF 19/03 pathogen was most aggressive, reducing the yield of healthy mushrooms by up to 64% for the PB 1/01 strain, and 49.6% for the ABI 19/01 strain. Additionally, for the same isolate, larger mushroom areas were affected, while also displaying symptoms precociously during the second flush. Finally, using the set of visually displayed symptoms assessed in this study, we were able to construct a diagrammatic scale to assist commercial mushroom growers for managing diseased crops.

Assuntos

RESUMO

The aim of the research was to verify the influence of macro and micronutrients present in the peanut waste (hulls and nuts) for supplementation of Pleurotus ostreatus substrate. The raw materials for base substrate preparation were Brachiaria dictyoneura, sugarcane bagasse (bulk material), rice and wheat bran, calcitic limestone, and gypsum. The following supplement formulations were used as treatments: (1) 100% peanut hulls, (2) 80% peanut hulls + 20% nuts, (3) 60% peanut hulls + 40% nuts, (4) 40% peanut hulls + 60% nuts, (5) 20% peanut hulls + 80% nuts, and (6) 100% nuts. A commercial supplement was also used as an additional treatment. The supplementation was done at spawning using the rates of 1% and 2% wet weight of the substrate. Positive correlations amongst yield and N content, and weight of mushroom and P and K content were verified with 1% supplement. A positive correlation between yield and Cu content, and a negative correlation between yield and Mn content were observed with 2% supplement. The use of peanut waste can be used as supplement for the production of P. ostreatus increasing biological efficiency up to 61%. A better combination can be reached with 20% peanut hulls + 80% nuts or 100% nuts. The addition of 2% supplement in the substrate provided greater yield than 1%.

Assuntos

RESUMO

The use of fungicides is common in mushroom cultivation, but no study was carried out applying reduced doses of fungicides in order to increase yield, taking account the hormesis effect. The aim of this manuscript was to verify the effects of different concentrations of fungicides to stimulate the productivity of different strains of Agaricus bisporus. Two stages were developed, an in vitro study to define the best concentration to be applied in the second experiment an agronomic study, which consisted of the application of the selected fungicides, in their respective concentrations, in an experiment carried out in the mushroom chamber. Clearly, the result of the hormesis effect on mushroom cultivation can be verified. The results obtained in the 1st stage of the study (in vitro) were not always reproduced in the 2nd stage of the study (in vivo). The kresoxim methyl active ingredient may be an important chemical agent, while strain ABI 15/01 may be an extremely important biological agent to increase yield in the study of hormesis effects.

Assuntos

RESUMO

Agaricus subrufescens Peck is a basidiomycete with immunomodulatory compounds and antitumor activities. This research evaluated the mycochemical composition of A. subrufescens, considering their morphological and physiological stage of maturity, with a particular focus on the development of a traceability process for the formulation of new nutritional products based on fungal foods. The stipes contained a high amount of dry matter (10.33%), total carbohydrate (69.56%), available carbohydrate (63.89%), and energy value (363.97 kcal 100 g-1 DM). The pilei contained a high amount of moisture (90.66%), nitrogen (7.75%), protein (33.96%), ash (8.24), crude fat (2.44%), acid detergent fiber (16.75 g kg-1), neutral detergent fiber (41.82 g kg-1), hemicellulose (25.07 g kg-1), and lignin (9.77 g kg-1). Stipes with mature physiological stage had higher values of dry matter (10.50%), crude fiber (5.94%), total carbohydrate (72.82%), AC (66.88%), and energy value (364.91 kcal 100 g-1 DM). Pilei of the mushrooms in the immature physiological stage had higher values of P (36.83%), N (8.41%), and A (8.44%). Due to the differences between the mycochemical compositions of the morphological parts of mushrooms linked to their physiological stage of maturity, such characteristics have immense potential to be considered for a traceability process. This study can be used for the purpose of providing the consumer with more product diversity, optimizing bioactivities of composts, and allowing farmers an efficient and profitable use of the mushroom biomass.

Assuntos

RESUMO

The present work aimed to assess the effect of the following treatments on the medicinal potential (ß-glucan content) and agronomical performance (yield) of Agaricus subrufescens: five different fungal strains, three cultivation substrates (compost), four casing layers, and four cultivation environments. Two experiments were performed, and the results indicate that the greatest contribution to the variation in ß-glucan content was the strain (35.8%), followed by the casing layer (34.5%), the cultivation environment (15.7%), and the type of compost (9.9%). On the other hand the variation in yield was affected most by the cultivation environment (82.1%), followed by the strain (81.3%), casing layer (49.1%), and compost type (15.2%). These findings underscore the importance of developing a production protocol that employs specific cultivation practices for improving mushroom yield as well as ß-glucan content.

Assuntos

RESUMO

BACKGROUND: Agaricus subrufescens Peck is a mushroom whose cultivation has aroused great interest worldwide in recent years, and is becoming increasingly popular. A rapid expansion of culture throughout the world is foreseen because of its medicinal and culinary properties. AIMS: This work assesses the effect of 5 different casing layers on the production of 3 strains of Agaricus subrufescens. METHODS: A growth cycle of Agaricus subrufescens under controlled conditions has been carried out. The main production parameters were evaluated. RESULTS: The best results were provided by the ABL 99/30 strain. Peat-based casings have a better yield than those based on mineral soil. The highest yield (6.75kg/m(2), biological efficiency 27.57kg/dt) was provided by the combination ABL 99/30-Euroveen. CONCLUSIONS: Our results suggest that the combination of the strain ABL 99/30 using a peat-based casing layer (Euroveen) offers a high potential for use on a commercial scale by the edible mushroom production sector. The availability of alternatives to the usually cultivated species can make better use of resources, and increase the profitability of this activity.

Assuntos