RESUMEN

The present study focused on preparing rohu egg sauce using optimized conditions through enzymatic and fermentative methods. The enzymatic preparation of rohu egg sauce (ERS) involved homogenizing the eggs in water at a ratio of 1:0.9 (w/v), followed by the addition of salt (20% w/w) and papain (3% w/w). A mixture containing salt (25% w/w), sugar (7.5% w/w), and inoculum (10% (w/v)) of Pediococcus pentosaceus FSBP4-40 was utilized to prepare fermentatively produced rohu egg sauce (FRS). ERS and FRS were then stored at room temperature (25 ± 2 °C) and 37 °C for 180 days. After storage, both sauces were evaluated for their scavenging activity against DPPH, ABTS, and superoxide anion (SOA). The ERS demonstrated significantly higher DPPH, ABTS, and SOA scavenging activity compared to the FRS, with values of 61.61 ± 7.33%, 71.21 ± 2.14%, and 85.11 ± 4.92%, respectively, as opposed to 37.49 ± 5.34, 52.31 ± 1.76%, and 63.09 ± 2.31%. Significant changes were observed in the fatty acid profile of the sauces during 180 day storage. Furthermore, after 180 days, the bacterial counts in the FRS were much lower than in the ERS. Overall, this study highlights the importance of using enzymes and LAB in accelerating the hydrolytic process to produce biofunctional rohu egg sauce.

RESUMEN

Heavy metal discharge from various metallurgical industries has been of particular concern in India over the last few decades. Similarly, management and disposal of wastes that are generated out of agricultural commodities processing is a huge task for processors. The researchers have been focusing on a new process for remediation of heavy metals, among which biosorption is an emerging technology. Adsorption using agricultural and food industry wastes (AFW) has shown a greater absorption rate than the conventional system due to the presence of the functional groups. In addition, these reported AFW exhibited better adsorption efficiency when modified with acid, alkaline, and other chemical solvents. In this context, utilization of agricultural and food waste as bio-sorbent could simultaneously benefit both water treatment and waste management. This review seeking to address the possibilities of using biosorption as green technological approach for removal of heavy metals and also focuses on various parameters that are required to use AFW as an efficient system for biosorption. However, commercialization and implementation of this process in industrial scale is necessary for successfully utilizing AFW as low-cost adsorbents. Supplementary Information: The online version contains supplementary material available at 10.1007/s13197-022-05486-1.

RESUMEN

Cold plasma technology is considered as one of the novel potential non-thermal techniques for food disinfection. The acceptability of any food product depends upon its physicochemical properties and shelf life. Recent studies have confirmed that plasma can effectively reduce the pathogenic microbes in various food systems. Further, there are reports that cold plasma showed minimal or no effect on the physicochemical and sensory properties of the foods owing to its low-temperature operation. The present review explores the recent reports on cold plasma technology emphasizing its disinfection efficacy on different food categories. Various researchers have demonstrated that plasma successfully reduced the microorganisms on cereals, milk, meat, fish and spices. Therefore, based on the current research, it can be suggested that cold plasma is an effective disinfectant technology for the inactivation of pathogenic microorganisms, and its non-thermal and environmentally friendly nature is an added advantage over traditional processing technologies.

Asunto(s)

RESUMEN

Protein hydrolysates were prepared from chicken liver using fermentation and enzymatic hydrolysis. The lactic acid bacteria Pediococcus acidilactici NCIM5368 was employed in the fermentation process and a commercial protease (Alcalase® 2.5) was used in enzymatic hydrolysis. Chicken liver hydrolysates prepared by fermentation (FCLH) and enzymatic hydrolysis (ECLH) revealed appreciable amounts of protein [55.85 and 61.34 %; on dry weight basis, respectively]. Fermentation and enzymatic hydrolysis resulted in 14.3 and 26.12 % of degree of hydrolysis. Total antioxidant activity, reducing power, scavenging of superoxide, 2- diphenyl-1-picrylhydrazyl (DPPH) and 2, 2-azino-bis-3-ethyl-benzthiazoline-6-sulphonic acid (ABTS) radicals were determined for both FCLH & ECLH. FCLH & ECLH showed total antioxidant activity of 0.99 and 1.13 µg AAE mg(-1) proteins, respectively; while, they scavenged 96.14 and 92.76 % of DPPH radicals respectively. FCLH showed higher ABTS radical scavenging activity (32.16 %) than ECLH (19.29 %). Superoxide anion scavenging activity of FCLH & ECLH were found to be 95.02 & 88.94 %, respectively. Residues obtained after both treatments also exhibited antioxidant activities. FCLH reported highest antagonistic activity against Listeria monocytogenes (30 mm); while, ECLH showed antibacterial activity only against Micrococcus luteus (12 mm). Both hydrolysates have the potential to be a protein rich ingredient for use in formulated foods and possible help in reduction of oxidative stress.

RESUMEN

Severe flooding of the Brahmaputra River during the monsoon season and continuous rainfall in the northeast region (NER) of India cause an enormous loss of ginger crop every year. In this context, the present study investigates the variation in the essential oil composition and oleoresin and [6]-gingerol contents in 10 different fresh ginger cultivars harvested at 6- and 9-month maturity from five different states of NER. Monoterpenes, sesquiterpenes, and citral composition in the essential oil were evaluated to ascertain their dependence upon the maturity of ginger. Except Mizoram Thinglaidum, Mizoram Thingria, Nagaland Nadia, and Tripura I ginger cultivars, all other cultivars showed an increase in the citral content during the maturity that was observed for the first time. At 6-month maturity, a higher undecanone level was found in Nagaland Nadia (7.36 ± 0.61%), Tripura I (6.23 ± 0.61%), and Tripura III (9.17 ± 0.76%) cultivars, and these data can be used as a benchmark to identify those immature varieties. Interestingly, the Nagaland Nadia cultivar showed higher ar-curcumene (9.57 ± 0.58%) content than zingiberene (5.84 ± 0.24%), which was unique among all cultivars. Ginger harvested at 9-month maturity from the Tripura II cultivar had the highest citral content (22.03 ± 0.49%), and the Meghalaya Mahima cultivar had the highest zingiberene content (29.89 ± 2.92%). The oleoresin content was found to decrease with maturity in all cultivars, except Assam Fibreless and Manipur I. Moreover, the highest oleoresin (11.43 ± 0.58 and 9.42 ± 0.63%) and [6]-gingerol (1.67 ± 0.03 and 1.67 ± 0.05 g) contents were observed for Tripura II and Nagaland Nadia, respectively. This study suggests that Tripura and Nagaland are the most ideal locations in NER for ginger cultivation to obtain high yields of oleoresin and [6]-gingerol contents and harvesting at the 6-month maturation will compensate for the loss of ginger crop caused by the Brahmaputra River flooding in NER every year.

Asunto(s)