Moslae Herba is a commonly used aromatic Chinese medicinal with volatile oil as the main effective component and exhibits broad-spectrum antibacterial and antiviral effects. However, the irritation and instability of Moslae Herba volatile oil necessitate the preparation into a specific dosage form. In this study, the steam distillation method was employed to extract the Moslae Herba volatile oil. The content of thymol and carvacrol in Moslae Herba volatile oil was determined by HPLC as(0.111 9±0.001 0) and(0.235 4±0.004 7) mg·mL~(-1), respectively. Pseudo-ternary phase diagrams and surfactants compounding were applied in the selection of the optimal excipients(surfactant and cosurfactant). On this basis, a nanoemulsion was prepared from the Moslae Herba volatile oil and then loaded into pressure vessels to get sprays, whose stability and antibacterial activity were evaluated afterward. With clarity, viscosity, smell and body feeling as comprehensive indexes, the optimal formulation of the Moslae Herba volatile oil nanoemulsion was determined as follows: Moslae Herba volatile oil∶peppermint oil∶cremophor EL∶absolute ethanol∶distilled water 7.78∶1.58∶19.26∶6.15∶65.23. The as-prepared nanoemulsion was a light yellow transparent liquid, with Tyndall effect shown under the irradiation of parallel light. It has the pH of 5.50, conductivity of 125.9 μS·cm~(-1), average particle size of 15.45 nm, polydispersity index(PDI) of 0.156, and Zeta potential of-17.9 mV. Under a transmission electron microscope, the Moslae Herba volatile oil nanoemulsion was presented as regular spheres without adhesion and agglomeration. Stability test revealed that the Moslae Herba volatile oil nanoemulsion was stable at 4-55 ℃, which was free from demulsification and stratification within 30 days. After the centrifugation at 12 000 r·min~(-1) for 30 min, there was no stratification either. The nanoemulsion had good inhibitory effects on Escherichia coli, Staphylococcus aureus and resistant S. aureus strains, with the minimum inhibitory concentrations of 0.39, 3.12 and 1.56 mg·mL~(-1), respectively. The above results demonstrated that the nanoemulsion was prepared feasibly and showed stable physical and chemical properties and good antibacterial effects. This study provides a practicable technical solution for the development of anti-epidemic and anti-infection products from Moslae Herba volatile oil.