RESUMO

Soil pollution with potentially toxic elements (PTE) from incipient basic sanitation, dumps and industrial activities developed in the Amazon has been of international interest due to health and environmental issues. This study aimed to evaluate the concentration of PTE in five adjacent land occupations (a dump, a alumina refinery area and three residential centers) in the municipality of Barcarena, Amazon Region, Brazil. In a total area of 912 ha, 274 soil samples were collected at a depth of 0-0.2 m. Afterwards, the concentrations of As, Ba, Pb, Co, Cu, Cr, Hg, Ni and Zn were determined. The results were explored using descriptive and multivariate statistics, as well as geostatistical. Considering the data by location, maximum concentrations exceeding the prevention values of Brazilian soils were found for Cu, Ni and Zn in Dump (148; 42.8 and 356 mg kg-1), for Cu and Hg in Bom Futuro (333 and 1.99 mg kg-1) and for Cu in Itupanema (91.2 mg kg-1). Cu, Hg, Pb and Zn were grouped in the same principal component and showed the highest similarity measure in the cluster analysis. The interpolation point maps of the two principal components and of the individual concentrations of the PTEs showed the area of influence of the dump as the main reason for the increase in soil contamination. These results show the need for public policies aimed at the proper disposal of solid waste, in order to promote the reduction of pollutants in the soil, health and well-being for the local population, and also the environmental quality of the study area.

RESUMO

This study simulates the spillage of 1460 metric tons of oil that occurred in January 2022 off La Pampilla Refinery, in central Perú. The oil slick was predominantly displaced northward along the coastline, driven by prevailing currents and winds in the region. The weathering analysis revealed that the removal of oil was mainly due to evaporation (28%) and beaching processes (70%) within 96 h after the initial release. The coastal areas spanning from Ventanilla to Punta Chancay experienced significant impacts from the oil spill, representing 96% of the total affected coastal extent. Specifically, Ventanilla and Santa Rosa Beaches and the National Reserve System of Islands were heavily impacted during the first 24 h, while the surroundings of Ancón Bay, Aucallama and Pasamayo beaches were affected after two days. This modeling case study provides valuable insights into the fate and transport of the Repsol oil spill.

Assuntos

RESUMO

Among the waste generated at oil refineries, secondary sludge from biological wastewater treatment processes (activated sludge systems) stands out. This paper aimed to assess the use of anaerobic digestion (AD) to treat sludge by SWOT (Strength, Weakness, Opportunity, and Threat) analysis, ranking the different factors based on sustainability criteria. Additionally, the SWOT factors were matched (TOWS matrix) to help interpret the results. AD was found to be compatible with sustainability. The results demonstrated that the strength of AD (reduced organic load) compensates for its weaknesses (need for operational control and initial implementation costs), thereby avoiding the threat (sludge composition) and making the most of the opportunity (lower disposal cost). AD and co-digestion (added with food waste) used to treat oil refinery sludge showed that around 60% of the factors analyzed were confirmed experimentally. It was concluded that AD should be considered in the sustainable treatment of oil refinery waste activated sludge, especially when mixed with other readily biodegradable wastes.

Anaerobic digestion (AD) is a potential treatment for secondary sludge from refineries.AD is compatible with sustainability.Anaerobic co-digestion of refinery sludge contributed positively to sustainable treatment.The strength (reduced organic load) of AD counteract its weaknesses (operational control and implementation costs).The threat of AD (sludge composition) should be avoided and the opportunity (low disposal cost) leveraged.

Assuntos

RESUMO

A flare stack is an indispensable device in the oil and gas industry for allowing the safe combustion of gases into the atmosphere, especially during emergencies. However, it is not ideal for the routine disposal of gaseous waste, as it is subject to meteorological influences and poor operational control. In addition, it can be affected by toxic currents and thus pose a potential risk of odors; in view of this, an assessment must be made of the implications of burning on the environment and health. Atmospheric dispersion modelling has proved to be a very useful tool for this purpose. In light of this, an attempt has been made in this work to evaluate the impact of H2S on the well-being (odor perception) of the community in the surrounding area of an oil refinery, where the temporary burning of rich gas in H2S occurs in a chemical flare, and operational factors have an influence on atmospheric dispersion. The odor assessment was carried out with the aid of AERMOD which was adapted to estimate the maximum odor concentration for very short periods by means of peak-to-mean ratios. The results showed that H2S detection can reach a probability rate of 42% at 3.5 km distance from the flare (in a time interval of 5 s) with a relatively high degree of annoyance (3.0 AU). However, some operational procedures can reduce the probability of odor detection to 29% and the degree of annoyance to 2.6 AU.

Assuntos

RESUMO

The technology of anaerobic co-digestion to treat the excess biological sludge discharged from activated sludge systems in oil refineries was evaluated in bench scale experiments. Mixing food waste rich in fruits and vegetables with this sludge increased the reduction of volatile solids and biogas yield. An experimental design indicated that the best co-digestion condition was the use of waste activated sludge without previous dewatering (3.5% total solids) and food waste in an 80:20 ratio (% v/v), without the addition of inoculum. After 45 days at 35 °C, this condition resulted in volatile solid (VS) removal of 52% and biogas yield of 80.7 mL biogas/g VSadded, against only 19% and 38.5 mL biogas/g VSadded in mono-digestion of sludge alone. Anaerobic co-digestion demonstrates promising results and the potential for a simple and effective treatment method for excess biological sludge generated at refineries.

Assuntos

RESUMO

The main objective of the current study was to assess the impact of the water taken from the 'Tunisian Refining Industries Company' on meiobenthic nematodes, before and after a series of treatments in decantation basins followed by its discharge in Bizerte bay, Tunisia. The comparison of environmental parameters of the two types of water was clearly indicative of an improvement in the quality of treated waters after a significant reduction in their loads in hydrocarbons. Overall, the water retained a good quality after being treated by 'Tunisian Refining Industries Company' before discharge in the sea. At the end of the experiment, differential responses were observed according to the richness of sediment in organic matter and hydrocarbons. Thus, it was apparent that the nematode assemblage exposed to the treated waters was closer to controls and associated to higher values of abundance, than that under untreated ones. It was also assumed that the species Microlaimus honestus De Man, 1922, Paramonohystera proteus Wieser, 1956 and Cyartonema germanicum Juario, 1972 are sensitive bioindicators of bad environmental statues and of hydrocarbon presence in the environment. On the other hand, Metoncholaimus pristiurus (Zur Strassen, 1894) Filipjev, 1918 would rather be classified as a positive bioindicative species of this type of pollutants.

O principal objetivo do presente estudo foi avaliar o impacto da água retirada da "Tunisian Refining Industries Company" sobre os nematoides meiobentônicos, antes e depois de uma série de tratamentos em bacias de decantação seguidos de seu descarte na baía de Bizerte, Tunísia. A comparação dos parâmetros ambientais dos dois tipos de água foi claramente indicativa de uma melhoria na qualidade das águas tratadas após uma redução significativa das suas cargas em hidrocarbonetos. No geral, a água reteve uma boa qualidade após ser tratada pela "Tunisian Refining Industries Company" antes da descarga no mar. Ao final do experimento, foram observadas respostas diferenciais de acordo com a riqueza de sedimentos em matéria orgânica e hidrocarbonetos. Assim, ficou claro que a assembleia de nematoides exposta às águas tratadas estava mais próxima dos controles e associada a maiores valores de abundância do que nas não tratadas. Também foi assumido que as espécies Microlaimus honestus De Man, 1922, Paramonohystera proteus Wieser, 1956 e Cyartonema germanicum Juario, 1972 são bioindicadores sensíveis de más estátuas ambientais e da presença de hidrocarbonetos no meio ambiente. Por outro lado, Metoncholaimus pristiurus (Zur Strassen, 1894) Filipjev, 1918 preferiria ser classificado como uma espécie bioindicativa positiva deste tipo de poluentes.

Assuntos

RESUMO

Abstract The main objective of the current study was to assess the impact of the water taken from the Tunisian Refining Industries Company on meiobenthic nematodes, before and after a series of treatments in decantation basins followed by its discharge in Bizerte bay, Tunisia. The comparison of environmental parameters of the two types of water was clearly indicative of an improvement in the quality of treated waters after a significant reduction in their loads in hydrocarbons. Overall, the water retained a good quality after being treated by Tunisian Refining Industries Company before discharge in the sea. At the end of the experiment, differential responses were observed according to the richness of sediment in organic matter and hydrocarbons. Thus, it was apparent that the nematode assemblage exposed to the treated waters was closer to controls and associated to higher values of abundance, than that under untreated ones. It was also assumed that the species Microlaimus honestus De Man, 1922, Paramonohystera proteus Wieser, 1956 and Cyartonema germanicum Juario, 1972 are sensitive bioindicators of bad environmental statues and of hydrocarbon presence in the environment. On the other hand, Metoncholaimus pristiurus (Zur Strassen, 1894) Filipjev, 1918 would rather be classified as a positive bioindicative species of this type of pollutants.

Resumo O principal objetivo do presente estudo foi avaliar o impacto da água retirada da Tunisian Refining Industries Company sobre os nematoides meiobentônicos, antes e depois de uma série de tratamentos em bacias de decantação seguidos de seu descarte na baía de Bizerte, Tunísia. A comparação dos parâmetros ambientais dos dois tipos de água foi claramente indicativa de uma melhoria na qualidade das águas tratadas após uma redução significativa das suas cargas em hidrocarbonetos. No geral, a água reteve uma boa qualidade após ser tratada pela Tunisian Refining Industries Company antes da descarga no mar. Ao final do experimento, foram observadas respostas diferenciais de acordo com a riqueza de sedimentos em matéria orgânica e hidrocarbonetos. Assim, ficou claro que a assembleia de nematoides exposta às águas tratadas estava mais próxima dos controles e associada a maiores valores de abundância do que nas não tratadas. Também foi assumido que as espécies Microlaimus honestus De Man, 1922, Paramonohystera proteus Wieser, 1956 e Cyartonema germanicum Juario, 1972 são bioindicadores sensíveis de más estátuas ambientais e da presença de hidrocarbonetos no meio ambiente. Por outro lado, Metoncholaimus pristiurus (Zur Strassen, 1894) Filipjev, 1918 preferiria ser classificado como uma espécie bioindicativa positiva deste tipo de poluentes.

RESUMO

The organization of the roots, ganglia and the peripheral distribution of the cranial nerves of the fully formed embryos of Oreochromis niloticus are examined in the transverse serial sections. These nerves carry fibers, which were also analyzed. The results of this study demonstrated that the glossopharyngeal nerve originates by means of only one root, which leaves the cranium through the glossopharyngeal foramen. This nerve gives fibers (visceromotor) to the first internal and external levator arcus branchialis muscles. There is a single epibranchial (petrosal) ganglion located extracranially. Nervus glossopharyngeus has three rami; pharyngeus, pretramticus and posttrematicus. The ramus pharyngeus carries only viscerosensory fibers; general for the pharyngeal epithelium and special ones for the pseudobranch. General viscerosensory fibers are also carried by rami pretrematicus and posttrematicus for the pharyngeal epithelial lining. The special sensory fibers are carried by the ramus pretrematicus for the taste buds and by ramus posttrematicus for the gill filaments. The ramus pretrematicus also carries visceromotor fibers for the first adductor arcus branchialis and to the first obliquus ventralis muscles.

A organização das raízes, gânglios e a distribuição periférica dos nervos cranianos dos embriões totalmente formados de Oreochromis niloticus são examinados nas seções transversais seriais. Esses nervos carregam fibras, que também foram analisadas. Os resultados deste estudo demonstraram que o nervo glossofaríngeo se origina por meio de apenas uma raiz, que sai do crânio pelo forame glossofaríngeo. Este nervo fornece fibras (visceromotoras) para os primeiros músculos levantadores do arco branquial interno e externo. Existe um único gânglio epibranquial (petroso) localizado extracranialmente. Nervus glossopharyngeus tem três ramos; faríngeo, pretramticus e póstrematicus. O ramo faríngeo contém apenas fibras viscerossensoriais ­ gerais para o epitélio faríngeo e especiais para o pseudobrânquio. Fibras viscerossensoriais gerais também são transportadas por ramos pretrematicus e posttrematicus para o revestimento epitelial da faringe. As fibras sensoriais especiais são transportadas pelo ramus pretrematicus para as papilas gustativas e pelo ramus posttrematicus para os filamentos branquiais. O ramo pretrematicus também carrega fibras visceromotoras para o primeiro adutor arcus branchialis e para o primeiro músculo oblíquo ventral.

Assuntos

RESUMO

The main objective of the current study was to assess the impact of the water taken from the 'Tunisian Refining Industries Company' on meiobenthic nematodes, before and after a series of treatments in decantation basins followed by its discharge in Bizerte bay, Tunisia. The comparison of environmental parameters of the two types of water was clearly indicative of an improvement in the quality of treated waters after a significant reduction in their loads in hydrocarbons. Overall, the water retained a good quality after being treated by 'Tunisian Refining Industries Company' before discharge in the sea. At the end of the experiment, differential responses were observed according to the richness of sediment in organic matter and hydrocarbons. Thus, it was apparent that the nematode assemblage exposed to the treated waters was closer to controls and associated to higher values of abundance, than that under untreated ones. It was also assumed that the species Microlaimus honestus De Man, 1922, Paramonohystera proteus Wieser, 1956 and Cyartonema germanicum Juario, 1972 are sensitive bioindicators of bad environmental statues and of hydrocarbon presence in the environment. On the other hand, Metoncholaimus pristiurus (Zur Strassen, 1894) Filipjev, 1918 would rather be classified as a positive bioindicative species of this type of pollutants.(AU)

O principal objetivo do presente estudo foi avaliar o impacto da água retirada da "Tunisian Refining Industries Company" sobre os nematoides meiobentônicos, antes e depois de uma série de tratamentos em bacias de decantação seguidos de seu descarte na baía de Bizerte, Tunísia. A comparação dos parâmetros ambientais dos dois tipos de água foi claramente indicativa de uma melhoria na qualidade das águas tratadas após uma redução significativa das suas cargas em hidrocarbonetos. No geral, a água reteve uma boa qualidade após ser tratada pela "Tunisian Refining Industries Company" antes da descarga no mar. Ao final do experimento, foram observadas respostas diferenciais de acordo com a riqueza de sedimentos em matéria orgânica e hidrocarbonetos. Assim, ficou claro que a assembleia de nematoides exposta às águas tratadas estava mais próxima dos controles e associada a maiores valores de abundância do que nas não tratadas. Também foi assumido que as espécies Microlaimus honestus De Man, 1922, Paramonohystera proteus Wieser, 1956 e Cyartonema germanicum Juario, 1972 são bioindicadores sensíveis de más estátuas ambientais e da presença de hidrocarbonetos no meio ambiente. Por outro lado, Metoncholaimus pristiurus (Zur Strassen, 1894) Filipjev, 1918 preferiria ser classificado como uma espécie bioindicativa positiva deste tipo de poluentes.(AU)

Assuntos

RESUMO

This paper presents an eco-efficiency analysis of five scenarios for treating a petrochemical unit effluent defined sequentially to increase the water reuse rate to the limit condition of Zero Liquid Discharge perspective. The base process, consisting of reverse osmosis, an evaporator and crystallizer, displayed pretreatment alternatives the addition of antifouling agents, desupersaturation of barium ions and coprecipitation of low solubility salts to increase osmosis efficiency. The eco-efficiency analysis applied the life cycle approach to verify environmental and energy performances and determined the costs of the treatment unit installation and operation for a time horizon of 9.5 years. The pretreatment increased water recovery during osmosis from 84% to over 97%. The environmental-energetic analysis indicated a strong influence of electric energy, consumed mainly during the thermal stages of the treatment, and of the chlorine-derived compounds used in the pretreatment. Also due to pre-treatment, it was possible to reduce impacts in terms of Global Warming Potential by up to 59%, and in Primary Energy Demand by 64% for the best scenario. The economic analysis depicted a significant influence of operating costs, and the electricity consumed in the processes is responsible for the largest share of expenses. The reuse water presented a cost ranging between US$ 1.08/m3 and US$ 1.80/m3. The systems with pretreatment by coprecipitation with Ca(OH)2 and CaCO3 and monoacids to adjust the pH of the final effluent showed to be more eco-efficient than the other options under analysis.

Assuntos

RESUMO

Biogas, a gaseous effluent from the anaerobic digestion of organic waste, is considered an important source of energy, since it has a composition mainly of methane (CH4; 55-75%) and CO2 (20-60%). Today, CO2 from biogas is an excellent carbon source to induce high microalgal biomass production; however, each microalga strain can have different optimal CO2 concentrations for maximizing their bio-refinery capacity as well as different ability to endure stressful conditions of industrial effluents. This study assessed the bio-refinery capacity of Chlorella sp. and Scenedesmus sp., native of Lago de Chapala, Mexico, from biogas, as well as the effect of high CO2 and methane concentrations on the physiological performance to grow, capture CO2 and biochemical composition of both microalgae cultured under different biogas compositions. The results show that both microalgae have the biotechnological potential to endure biogas compositions of 25% CO2-75% CH4. Under this condition, the biomass production attained by Chlorella sp. and Scenedesmus sp. was 1.77 ± 0.32 and 2.25 ± 0.20 g L-1, respectively, with a biochemical composition mainly of carbohydrates and proteins. Overall, this study demonstrates that both microalgae have the ability to endure the stressful biogas composition without affecting their physiological capacity to capture CO2 and biosynthesize high-value metabolites. Moreover, it is worth highlighting the importance of screening wild-type microalgae from local ecosystems to determine their physiological capacity for each biotechnological application.

Assuntos

RESUMO

The catalytic activity of Mn2O3, FeOOH and CeO2 nanoparticles was evaluated in the treatment of a synthetic petroleum refinery wastewater (SPRW) using O3 in a discontinuous reactor at 25°C and pH 5.5. The mineralization and partial chemical oxidation rates of SPRW using these metal oxides are in the same order of magnitude, and the catalytic activity in the mineralization of SPRW decreased in the order Mn2O3 > CeO2 > FeOOH. The mineralized fraction progressively increased with time in the catalytic process while in the non-catalytic process it remained constant. The effect of the operational conditions on the mineralization and partial chemical oxidation rates using Mn2O3 was investigated in detail. The mineralization rate was found to be lower than the partial oxidation rate due to the formation of partially oxidized by-products, and this is dependent on the solids dosage and pH. An investigation of the mechanism demonstrated that the enhancement effect could be attributed to the introduction of the manganese oxide nanoparticles, which could promote the utilization of O3 and/or enhance the formation of free radicals (•OH, •O2H and •O2-) on the solid surface and further accelerate the degradation of the organic compounds present in the wastewater.

Assuntos

RESUMO

Oil refineries are known for the large volume of water used in their processes, as well as the amount of wastewater generated at the end of the production chain. Due to strict environmental regulations, the recycling of water has now become a viable alternative for refineries. Among the many methods available to treat wastewater for reuse, the use of membranes in reverse osmosis systems stands out due to several economic and environmental benefits. However, these systems are vulnerable to contamination and deposition of microorganisms, mainly because of the feedwater quality. In this study, the microbial diversity of feedwater and reverse osmosis membranes was investigated using a combination of culture-dependent and culture-independent methods in order to characterize the microorganisms colonizing and deteriorating the membranes. In total, 37 bacterial isolates, 17 filamentous fungi and approximately 400 clones were obtained and analyzed. Among the bacterial genera identified, the most represented were Sphingobium, Acidovorax, Microbacterium, Rhizobium and Shinella. The results revealed genera that acted as candidate key players in initial biofilm formation in membrane systems, and provided important information concerning the microbial ecology of oligotrophic aquatic systems.

Assuntos

RESUMO

BACKGROUND: In many companies, investigations of accidents still blame the victims without exploring deeper causes. Those investigations are reactive and have no learning potential. OBJECTIVE: This paper aims to debate the historical organizational aspects of a company whose policy was incubating an accident. METHODS: The empirical data are analyzed as part of a qualitative study of an accident that occurred in an oil refinery in Brazil in 2014. To investigate and analyse this case we used one-to-one and group interviews, participant observation, Collective Analyses of Work and a documentary review. The analysis was conducted on the basis of concepts of the Organizational Analysis of the event and the Model for Analysis and Prevention of Work Accidents. RESULTS: The accident had its origin in the interaction of social and organizational factors, among them being: excessively standardized culture, management tools and outcome indicators that give a false sense of safety, the decision to speed up the project, the change of operator to facilitate this outcome and performance management that encourages getting around the usual barriers. CONCLUSIONS: The superficial accident analysis conducted by the company that ignored human and organizational factors reinforces the traditional safety culture and favors the occurrence of new accidents.

Assuntos

RESUMO

The oil refinery industry seeks solutions to reduce its water uptake and consumption by encouraging the reuse of internal streams and wastewater from treatment systems. After conventional treatment the petroleum refinery wastewater still contains a considerable quantity of recalcitrant organics and the adsorption on activated carbon is currently used in Brazilian refineries, although it is still expensive due to the difficulty of its regeneration. This study evaluated the use of adsorbent and ion exchange resins for the removal of organic matter from refinery wastewater after conventional treatment in order to verify its feasibility, applying successive resin regenerations and comparing the results with those obtained for activated carbon process. Adsorption isotherms experiments were used to evaluate commercial resins, and the most efficient was subjected to column experiments, where absorbance (ABS) and total organic carbon (TOC) removal were measured. The adsorption isotherm of the best resin showed an adsorptive capacity that was 55% lower than that of activated carbon. On the other hand, the column experiments indicated good removal efficiency, and the amount of TOC in the treated wastewater was as good as has been reported in the literature for activated carbon. The regeneration efficiency of the retained organics ranged from 57 to 94%, while regenerant consumption ranged from 12 to 79% above the amount recommended by the resin supplier for the removal of organic material from natural sources, showing the great resistance of these recalcitrant compounds to desorption. Finally, an estimate of the service life of the resin using intermediate regeneration conditions found it to be seven times higher than that of activated carbon when the latter is not regenerated.

Assuntos

RESUMO

Direct (UV) and hydrogen peroxide-assisted (UV/H2O2) photolysis were investigated in bench-scale for removing the organic compounds present in the electrodialysis reversal (EDR) brine from a refinery wastewater reclamation plant. In the UV/H2O2 experiments, a COD:H2O2 molar ratios of 1:1, 1:2 and 1:3 were tested by recirculating the brine in the UV reactor for 120 min. Results showed a significant reduction in UVA254, whereas no reduction was observed for chemical oxygen demand (COD), in the UV process, suggesting great cleavage but limited mineralization of the organic matter. UV/H2O2 with C:H2O2 ratio of 1:3 exhibited high efficiency in removing the organic matter (COD removal of 92% with an electrical energy per removal order (EEO) value of 22 kW h m-3). Although the EDR brine has high salinity, no strong scavenging effect of •OH was found in the water matrix due to the high concentration of anions, especially chloride and bicarbonate. Finally, UV/H2O2 with C:H2O2 ratio of 1:3 and residence time of 120 min is an efficient alternative for organic matter removal of EDR brine from refinery wastewater reclamation plant showing total capital cost (CapEx) estimated at US$ 369,653.00 and total operational cost (OpEx), at US$ 1.772 per cubic meter of effluent.

Assuntos

RESUMO

This study aims to evaluate membrane bioreactor (MBR) performance in a pilot scale to treat petroleum refinery effluent, and has been primarily focused on (1) investigation of dynamics of organic matter removal; (2) characterization of membrane fouling under real hazardous events; (3) evaluation of the effect of fouling on membrane lifetime; and (4) estimate the membrane lifetime. The results have shown that the MBR was able to effectively reduce COD, NH3-N, turbidity, color, phenol and toxicity, and bring them to the levels required to meet disposal and non-potable water reuse standards. The FTIR results showed that organic matter was removed by biological oxidation and/or retained by adsorption in the biological sludge, or retention in the UF membrane, and that SMP was produced during the treatment. In terms of membrane permeability, the results showed that soluble fraction of mixed liquor contributed significantly to membrane fouling. And finally, considering the concept of lifetime based on permeability decline, a membrane lifetime of 7 years is expected.

Assuntos

RESUMO

A novel facility from the green technologies to integrate biomass-based carbohydrates, lignin, oils and other materials extraction and transformation into a wider spectrum of marketable and value-added products with a zero waste approach is reviewed. With ever-increasing scientific knowledge, worldwide economic and environmental consciousness, demands of legislative authorities and the manufacture, use, and removal of petrochemical-based by-products, from the last decade, there has been increasing research interests in the value or revalue of lignocellulose-based materials. The potential characteristics like natural abundance, renewability, recyclability, and ease of accessibility all around the year, around the globe, all makes residual biomass as an eco-attractive and petro-alternative candidate. In this context, many significant research efforts have been taken into account to change/replace petroleum-based economy into a bio-based economy, with an aim to develop a comprehensively sustainable, socially acceptable, and eco-friendly society. The present review work mainly focuses on various aspects of bio-refinery as a sustainable technology to process lignocellulose 'materials' into value-added products. Innovations in the bio-refinery world are providing, a portfolio of sustainable and eco-efficient products to compete in the market presently dominated by the petroleum-based products, and therefore, it is currently a subject of intensive research.

Assuntos

RESUMO

In recent years concern about the chemical composition of wastewater generated by the oil refining industry has increased, even after its treatment. These wastewaters contain substances that can harm both the entire aquatic ecosystem and the health of any exposed organisms. The aim of this study was to evaluate the genotoxic and mutagenic potentials of the effluent generated by the largest Brazilian petroleum refinery, the effectiveness of the treatments used by the refinery, and whether its effluent can compromise the water quality of the river where it is discarded. Chromosomal aberration and micronucleus assays were performed in Allium cepa and micronucleus test in mammalian cell culture (CHO-K1). The samples were collected in three sites at the refinery: one site on the Jaguari River and two sites on the Atibaia Rivers (upstream and downstream of the discharged effluent), under three different climatic conditions. Tests with A. cepa showed increased frequencies of chromosomal aberrations and micronuclei in meristematic cells for the effluent after physico-chemical treatment, but the samples after treatment biological and stabilization pond presented none of these abnormalities. It was observed that the induced damage in the meristematic cells was not observed in the F1 cells of A. cepa roots. The micronucleus test performed with mammalian cell culture also indicated that the effluent, after physico-chemical treatment, induced a significant increase in micronucleus frequencies. Plant and hamster cells exposed to the other samples collected inside the refinery and in the Jaguari and Atibaia Rivers did not present evidence of genotoxicity and mutagenicity in the tests performed. This study showed that the effluent treated carried out by the refinery (biological treatment followed by a stabilization pond) proved to be efficient for the removal of the toxic load still present after the physico-chemical treatment, since no change in the quality of the Atibaia River was observed. However, because this is an industry with a high production of effluent with toxic potential, its effluents must be constantly monitored, so that there is no compromise of the water quality of the receiving river.

Assuntos

RESUMO

Background: Sulphur-oxidizing microorganisms are widely used in the biofiltration of total reduced sulphur compounds (odorous and neurotoxic) produced by industries such as the cellulose and petrochemical industries, which include high-temperature process steps. Some hyperthermophilic microorganisms have the capability to oxidize these compounds at high temperatures (N60°C), and archaea of this group, for example, Sulfolobus metallicus, are commonly used in biofiltration technology. Results: In this study, a hyperthermophilic sulphur-oxidizing strain of archaea was isolated from a hot spring (Chillán, Chile) and designated as M1. It was identified as archaea of the genus Sulfolobus (99% homology with S. solfataricus 16S rDNA). Biofilms of this culture grown on polyethylene rings showed an elemental sulphur oxidation rate of 95.15 ± 15.39 mg S l-1 d-1, higher than the rate exhibited by the biofilm of the sulphur-oxidizing archaea S. metallicus (56.8 ± 10.91 mg l-1 d-1). Conclusions: The results suggest that the culture M1 is useful for the biofiltration of total reduced sulphur gases at high temperatures and for other biotechnological applications.

Assuntos