RESUMO
Microalgal biomass (MB) is a promising feedstock for bioenergy production. Nonetheless, the cell recalcitrance and the low C/N ratio limit the methane yield during anaerobic digestion. As an alternative to overcome these challenges, MB co-digestion with different feedstocks has been proposed. Thus, this study evaluated the anaerobic co-digestion (AcoD) of MB cultivated in wastewater with sugarcane vinasse (VIN) and residual glycerol from biodiesel production (GLY). Batch tests were conducted using augmented simplex-centroid mixture design to investigate the impact of AcoD on methane production (SMP), synergistic effects, and the influence on microbial community. When compared to MB digestion, 150 NmL CH4.g-1VS, binary and ternary AcoD achieved SMP increases from 120 to 337%. The combination of 16.7:16.7:66.7 (MB:VIN:GLY) showed the highest SMP for a ternary mixture (631 NmL CH4.g-1VS). Optimal synergies ranged from 1.3 to 1.4 and were primarily found for the MB:GLY AcoD. Acetoclastic Methanosaeta genus was predominant, regardless the combination between substrates. Despite the largest SMP obtained from the MB:GLY AcoD, other ternary mixtures were also highly synergetic and therefore had strong potential as a strategic renewable energy source.
RESUMO
The Anaerobic Digestion Model No. 1 (ADM1) was employed to simulate methane (CH4) production in an anaerobic reactor (AR), and the associated bench-scale biochemical methane potential (BMP) assay, having sewage sludge (SWS) from a municipal wastewater treatment plant (WWTP) as feedstock. The SWS presented the following physical-chemical characteristics: pH (7.4-7.6), alkalinity (2,382 ± 100 mg CaCO3 L-1), tCOD (21,903 ± 1,000 mg L-1), TOC (895 ± 100 mg L-1), TS, TVS, and VSS (2.0%, 1.1%, and 0.8%, respectively). The BMP assay was conducted in six replicates under anaerobic mesophilic conditions (37 ± 0.1°C) for 11 days with a CH4 yield registered of 137.6 ± 6.39 NmL CH4 or 124 ± 6.72 CH4 g-1 VS-1. When the results obtained with the BMP bench-scale reactors were compared to the output generated with computational data by the ADM1 model having as input data the same initial sewage tCOD, similar cumulative CH4 production curves were obtained, indicating the accuracy of the ADM1 model. This approach allowed the characterization of the sludge and estimation of its biogas production potential. The combination of BMP assays, experimental data, and ADM1 model simulations provided a framework for studying anaerobic digestion (AD) processes.
Assuntos
Biocombustíveis , Esgotos , Esgotos/análise , Biocombustíveis/análise , Metano/análise , Anaerobiose , Reatores BiológicosRESUMO
ABSTRACTSugarcane is the most traded crop in the world, with Brazil being the world's largest producer. Sugarcane processing generates up to 28% of sugarcane bagasse (SB) from the entire plant, with only 50% of it used for energy generation. SB is a lignocellulosic biomass that can be converted into biogas. However, the optimization of pretreatment process parameters is essential for its successful scaling up. This study evaluated the effect of mild alkaline pretreatment of SB using NaOH and KOH at concentrations of 1-10% and exposure time of 1-12â hours) on the biochemical methane potential (BMP) under mesophilic temperature. The central composite rotatable design (CCRD) was applied as statistical tool to generate optimal operating pretreatment conditions. The tests were performed in triplicates totalizing 84 batch bottles. The BMP of the untreated SB varied between 297-306 LN CH4 kg VS-1 while the BMP of the pretreated samples with NaOH and KOH were 19% and 20% higher. The optimized conditions were NaOH at 7.7% and KOH at 8.3% KOH for 12â hours. However, the range indicated by the statistical design with CCRD revealed that there was no statistical difference in terms of methane yield when concentrations between 4-10% NaOH and 6-10% KOH during 12â hours were applied, when compared to the specific optimized points. The optimization of the pretreatment parameters demonstrated to be a key-factor to improve the anaerobic digestion of lignocellulosic substrates, leading to a less chemically dependent and more sustainable approach, while allowing a more profitable process.
Assuntos
Celulose , Saccharum , Hidróxido de Sódio , Metano , Biocombustíveis , AnaerobioseRESUMO
In the last decade, Sargassum spp. seaweed species have caused massive flooding on the Caribbean Sea coasts. These seaweed species have a high content of recalcitrant compounds, such as insoluble fibers and polyphenols, which generate low methane yields in anaerobic digestion (AD). This study investigated the effect of solid-liquid separation of Sargassum biomass on biodegradability and methane yield. A biochemical methane potential (BMP) test was conducted with both fractions and raw biomass (RB). A mass balance was developed to assess the distribution of the components. The obtained liquid fraction (LF) showed high biodegradability and a high methane production rate, and it generated a methane yield of 159.7 ± 7.1 N L kg VS-1, a value that corresponds to approximately twice that achieved with RB and the solid fraction (SF). The component distribution analysis showed that about 90% of total solids (TS), volatile solids (VS), ash, carbon, and cellulose were retained in the SF. In conclusion, the LF had high biodegradability and methane yield. This suggests the potential for LFs of Sargassum biomass to be treated in large-scale high-load reactors; however, studies applied to SFs are needed because they retain a large amount of organic matter with low biodegradability.
Assuntos
Reatores Biológicos , Sargassum , Anaerobiose , Biomassa , Região do Caribe , Metano , BiocombustíveisRESUMO
This study evaluated the combination of bioprocesses to increase the utilization of agro-industrial poultry wastes. Composting piles were submitted to hydration and fraction separation (FS) and then, the solid fraction was vermicomposted and the liquid fraction was anaerobically digested. Composting followed by hydration and FS prior to vermicomposting enhanced earthworm adaptation and survival by reducing salt levels (50%), total organic carbon, and total nitrogen which may be limiting to vermicomposting at high concentrations. These strategies providing the production of up to 300 new cocoons and 360 young earthworms more than the control treatment. In addition to providing a favorable environment for earthworm growth, the combination of bioprocesses resulted in a high-quality organic fertilizer free of phytotoxic compounds and with phytostimulant properties (germination index higher than 100%). Energy recovery was greater in the treatment without the precomposting step (T0) (461.8 L CH4 kg-1. Volatile Solidsadded). The results show that combining the bioprocesses is a sustainable alternative for managing poultry wastes not only in terms of the recycling of nutrients but also by providing a clean source of energy.
Assuntos
Compostagem , Oligoquetos , Gerenciamento de Resíduos , Anaerobiose , Animais , Resíduos Industriais , Aves Domésticas , SoloRESUMO
Methane (CH4) production from anaerobic digestion of solid and liquid agro-industrial wastes is an attractive strategy to meet the growing need for renewable energy sources and promote environmentally appropriate disposal of organic wastes. This work aimed at determining the CH4 production potential of six agro-industrial wastewaters (AWW), evaluating the most promising for methanization purposes. It also aims to provide kinetic parameters and stoichiometric coefficients of CH4 production and define which kinetic models are most suitable for simulating the CH4 production of the evaluated substrates. The AWW studied were swine wastewater (SW), slaughterhouse wastewater (SHW), dairy wastewater (DW), brewery wastewater (BW), fruit processing wastewater (FPW), and residual glycerol (RG) of biodiesel production. RG was the substrate that showed the highest methanization potential. Exponential kinetic models can be efficiently applied for describing CH4 production of more soluble substrates. On the other hand, logistic models were more suitable to predict the CH4 production of more complex substrates.
Assuntos
Reatores Biológicos , Águas Residuárias , Anaerobiose , Animais , Biocombustíveis , Resíduos Industriais , Metano , SuínosRESUMO
In Brazil, a significant amount of organic waste is produced in households and restaurants. This study thus aimed to determine the ideal conditions for generating methane from the treatment of household waste by anaerobic digestion, under mesophilic (37 °C) and thermophilic (55 °C) conditions, to determine the maximum organic loading rate (OLR) in the reactors, and to evaluate kinetic parameters by statistical models: Modified Gompertz, First-Order, Logistic and Transference functions. The experiments were conducted in anaerobic batch reactors. Different proportions of pre-prepared waste (PPW)/leftover waste (LW) were used: 100/0, 75/25, 50/50, 25/75, and 0/100 and different ORL: 0.15; 0.30; 0.45; 0.60; and 0.90 g TVS (Total Volatile Solids).L-1.d-1. For both conditions, the optimal proportions of PPW/LW were 100/0 and 75/25 %. Under mesophilic condition, the best results were observed (869 mL of CH4.g TVS-1). The maximum organic load was 0.30 g TVS.L-1.d-1. The best data adjustment was performed by the Transference function.
RESUMO
Anaerobic digestion treatment of brewer's spent yeast (SY) is a viable option for bioenergy capture. The biochemical methane potential (BMP) assay was performed with three different samples (SY1, SY2, and SY3) and SY1 dilutions (75, 50, and 25 % on a v/v basis). Gompertz-equation parameters denoted slow degradability of SY1 with methane production rates of 14.59-4.63 mL/day and lag phases of 10.72-19.7 days. Performance and kinetic parameters were obtained with the Gompertz equation and the first-order hydrolysis model with SY2 and SY3 diluted 25 % and SY1 50 %. A SY2 25 % gave a 17 % of TCOD conversion to methane as well as shorter lag phase (<1 day). Average estimated hydrolysis constant for SY was 0.0141 (±0.003) day(-1), and SY2 25 % was more appropriate for faster methane production. Methane capture and biogas composition were dependent upon the SY source, and co-digestion (or dilution) can be advantageous.
Assuntos
Biocombustíveis , Metano/metabolismo , Leveduras/metabolismo , Anaerobiose , Hidrólise , CinéticaRESUMO
The tons of organic waste that are annually generated by agro-industry, can be used as raw material for methane production. For this reason, it is important to previously perform biodegradability tests to organic wastes for their full scale methanization. This paper addresses biodegradability, methane production and the behavior of populations of eubacteria and archaeabacteria during anaerobic digestion of banana, mango and papaya agroindustrial wastes. Mango and banana wastes had higher organic matter content than papaya in terms of their volatile solids and total solid rate (94 and 75% respectively). After 63 days of treatment, the highest methane production was observed in banana waste anaerobic digestion: 63.89ml CH4/per gram of chemical oxygen demand of the waste. In the PCR-DGGE molecular analysis, different genomic footprints with oligonucleotides for eubacteria and archeobacteria were found. Biochemical methane potential results proved that banana wastes have the best potential to be used as raw material for methane production. The result of a PCR- DGGE analysis using specific oligonucleotides enabled to identify the behavior of populations of eubacteria and archaeabacteria present during the anaerobic digestion of agroindustrial wastes throughout the process.
Assuntos
Agricultura , Anaerobiose , Archaea/isolamento & purificação , Bactérias/isolamento & purificação , Biocombustíveis , Reatores Biológicos , Resíduos Industriais , Metano/biossíntese , Resíduos Sólidos , Archaea/metabolismo , Bactérias/metabolismo , Biodegradação Ambiental , Carica , DNA Bacteriano/análise , Mangifera , Metano/isolamento & purificação , Plantago , RNA Bacteriano/genética , RNA Ribossômico 16S/genética , Eliminação de Resíduos , RibotipagemRESUMO
Las toneladas de residuos orgánicos que se generan anualmente en la agroindustria pueden aprovecharse como materia prima para la producción de metano. Para que los residuos orgánicos se puedan convertir a metano a gran escala, es importante que previamente se realicen sobre ellos pruebas de biodegradabilidad; un parámetro importante que conviene establecer es su potencial bioquímico de metano. En el presente trabajo se estudió la biodegradabilidad, la producción de metano y el comportamiento de poblaciones de eubacterias y arqueobacterias durante la digestión anaerobia de residuos de plátano, mango y papaya provenientes de la agroindustria, adicionando un inóculo microbiano. Los residuos de mango y plátano tenían mayor contenido de materia orgánica (94 y 75 %, respectivamente) que el residuo de papaya con base en su relación sólidos volátiles/sólidos totales. Después de 63 días de tratamiento, la mayor producción de metano se observó en la digestión anaerobia del residuo de plátano: 63,89 ml de metano por g de demanda química de oxígeno del residuo. Los resultados del potencial bioquímico de metano demostraron que el residuo de plátano tiene el mejor potencial para ser usado como materia prima en la producción de metano. A través de un análisis por PCR-DGGE con oligonucleótidos específicos se logró evaluar el tamaño y la composición de las poblaciones de eubacterias y arqueobacterias presentes en la digestión anaerobia de residuos agroindustriales a lo largo del proceso.
The tons of organic waste that are annually generated by agro-industry, can be used as raw material for methane production. For this reason, it is important to previously perform biodegradability tests to organic wastes for their full scale methanization. This paper addresses biodegradability, methane production and the behavior of populations of eubacteria and archaeabacteria during anaerobic digestion of banana, mango and papaya agroindustrial wastes. Mango and banana wastes had higher organic matter content than papaya in terms of their volatile solids and total solid rate (94 and 75 % respectively). After 63 days of treatment, the highest methane production was observed in banana waste anaerobic digestion: 63.89 ml CH4/per gram of chemical oxygen demand of the waste. In the PCR-DGGE molecular analysis, different genomic footprints with oligonucleotides for eubacteria and archeobacteria were found. Biochemical methane potential results proved that banana wastes have the best potential to be used as raw material for methane production. The result of a PCR- DGGE analysis using specific oligonucleotides enabled to identify the behavior of populations of eubacteria and archaeabacteria present during the anaerobic digestion of agroindustrial wastes throughout the process.
Assuntos
Digestão Anaeróbia/métodos , Gerenciamento de Resíduos/métodos , Metano/biossíntese , Biodegradação Ambiental , Uso de Resíduos Sólidos , Agroindústria/prevenção & controle , Reciclagem/métodos , Análise da Demanda Biológica de Oxigênio/métodos , Resíduos de AlimentosRESUMO
Os objetivos deste artigo foram investigar as condições ambientais e operacionais favoráveis ao desenvolvimento do teste de biodegradabilidade anaeróbia para lixiviados de aterro sanitário. As condições avaliadas foram a relação alimento/microrganismo (A/M), aclimatação do lodo, e toxicidade devido à alta concentração de amônia. Os resultados indicaram que a relação A/M equivalente a 0,45 apresentou-se como a mais favorável à realização do teste, e que o lodo empregado apresentou boa capacidade de adaptação ao lixiviado, não demandando aclimatação prévia. O lixiviado em questão apresentou relativamente baixa biodegradabilidade anaeróbia, associado aos resultados de estudos de biodegradabilidade aeróbia anteriores que sugerem que uma significativa fração de matéria orgânica é refratária mesmo ao metabolismo aeróbio,indica que o tratamento físico-químico deve ser utilizado como forma de pré ou pós-tratamento.
The objectives of this article were to investigate the favorable environment and operational conditions to the development of the anaerobic biodegradability test for landfill leachate. The evaluated conditions were the relation food/microrganismo (A/M), seed acclimatization, and toxicity due to high ammonia concentration. The results indicated that A/M relation equivalent to 0,45 was presented as most favorable to the accomplishment of the test, and that the seed used presented good capacity of adaptation to the leachate, not demanding previous acclimatization. The leachate in question presented relatively low anaerobic biodegradability, and associated to the results of previous studies of aerobic biodegradability suggest that a significant fraction of organic substance is refractory to the aerobic and anaerobic metabolism, indicating that the physical-chemical treatment must be used as form of pre or post-treatment.