RESUMO

A incorporação de substâncias antimicrobianas, entre elas os óleos essenciais, em embalagens tem como objetivo minimizar a contaminação microbiana em alimentos. No entanto, essa utilização é limitada por critérios sensoriais, sendo necessário determinar a concentração mínima necessária para inibir o desenvolvimento de micro-organismos sem afetar sensorialmente as características do alimento. Assim, os objetivos dessa pesquisa foram: determinar a concentração inibitória mínima (CIM) de óleos essenciais (OE) para Listeria monocytogenes (LM); avaliar do efeito da combinação de óleos essenciais para a redução da população de LM; avaliar a combinação de compostos ativos presentes em óleos essenciais para a inibição de LM, Pseudomonas spp e Salmonella spp; avaliar in vitro e in situ a eficiência antimicrobiana do filme à base de alginato incorporado de compostos ativos presentes em óleos essenciais; determinar a disponibilidade dos compostos ativos incorporados ao filme pela determinação dos compostos fenólicos totais; caracterizar o filme frente às propriedades mecânicas e propriedades de barreira, e verificar a aceitação pelo consumidor, através da análise sensorial, de fatias de salame embaladas com o filme antimicrobiano. Constatou-se que a combinação de eugenol (0,01%) e limoneno (0,04%) apresentou um maior efeito para a redução da população de LM comparado ao uso individual desses compostos, confirmando, portanto, a existência de sinergismo entre esses dois compostos. Em relação à Pseudomonas spp, o sinergismo foi constatado quando as concentrações de eugenol (0,15%) e de limoneno (0,30%) foram utilizadas, no entanto, para Salmonella spp o mesmo efeito não foi observado. Em ensaios in vitro apesar do aumento na concentração de eugenol e limoneno incorporados à matriz do filme, não houve diferença significativa para os valores de zona de inibição antimicrobiana porém, em ensaios in situ, a utilização desse filme como embalagem primária promoveu a redução de 2 log UFC/g da população de LM até o 10º dia de análise permanecendo constante até o 30º dia o que não ocorreu com a combinação de eugenol (0,15%) e limoneno (0,3%). A quantificação dos compostos fenólicos totais nas amostras mostrou que há correlação entre o teor de compostos fenólicos extraídos da amostra do filme e o comportamento de LM. As propriedades mecânicas e de barreira do filme à base de alginato não foram significativamente afetadas pelas concentrações de eugenol e limoneno avaliadas neste estudo. O sabor, o aroma e a aparência das amostras de salame foram aceitos pelos provadores mostrando que o uso do filme à base de alginato incorporado com eugenol e limoneno é viável para a aplicação como embalagem antimicrobiana para o controle de L. monocytogenes em salame fatiado. Este resultado é considerado importante, pois em alimentos com atividade de água e valores de pH adequados à multiplicação desse patógeno e armazenados sob refrigeração, a temperatura é capaz de selecionar a microbiota presente no alimento, favorecendo a multiplicação de micro-organismos psicrotróficos, como L. monocytogenes

The incorporation of antimicrobial substances in packages aims at reducing food microbial contamination among which the phenolic compounds extract from plants have received special attention being natural and attending consumer demand. However, the use of these compounds is limited by sensory criteria and it is necessary to determine the minimum concentration required to inhibit the growth of microorganisms without affecting the sensory characteristics of the food. The aim of this research were: to determine the minimum inhibitory concentration (MIC) of essential oils (EO) for Listeria monocytogenes (LM); to evaluate effect of the combination of essential oils in order to reduce LM population; to evaluate the active compounds combination for the inhibition of LM, Pseudomonas spp, and Salmonella spp; to evaluate the antimicrobial efficiency in vitro and in situ of the alginate film incorporated with the active compounds; to determine the availability of the active compounds incorporated into the film for the determination of total phenolic compounds; to characterize the mechanical and barrier properties of the film, and to verify consumer acceptance of slices of salami packaged with the antimicrobial film. The combination of eugenol (0.01%) and limonene (0.04%) showed a greater effect for reducing LM population compared to the individual use of these compounds, confirming the existence of synergism between these two compounds. Regarding Pseudomonas spp, synergism was observed when the concentrations of eugenol (0.15%) and limonene (0.30%) were used, however, the same effect was not observed for Salmonella spp. In in vitro tests, despite of the increase in the concentration of limonene and eugenol incorporated in the film matrix, no significant difference for the antimicrobial inhibition zone values was observed. In in situ tests, the film containing eugenol (0.3%) and limonene (0.6%) promoted the reduction of 2 log CFU/g of LM population in sliced salami, while the combination of eugenol (0.15%) and limonene (0.3%) did not have the same effect. The quantification of the phenolic compounds in the film samples showed that there is correlation between the content of phenolic compounds extracted from the film sample and LM behavior. The mechanical properties of the barrier film and the alginate were not significantly affected by eugenol, and limonene concentrations evaluated in this study. The taste, flavor and appearance of the salami samples were accepted by the panel showing that the use of the alginate-based film incorporated with limonene and eugenol are feasible for use as antimicrobial packaging for the control of L. monocytogenes in sliced salami. This is an important result, because in food matrix with water activity and pH suitable for the pathogen growth, the storage under refrigerated condition is able to select the psycrothophic microorganisms, such as L. monocytogenes

Assuntos

RESUMO

This study evaluated the effects of irradiation on the reduction of Shiga toxin-producing Escherichia coli (STEC), Salmonella strains, and Listeria monocytogenes, as well as on the sensory characteristics of minimally processed spinach. Spinach samples were inoculated with a cocktail of three strains each of STEC, Salmonella strains, and L. monocytogenes, separately, and were exposed to gamma radiation doses of 0, 0.2, 0.4, 0.6, 0.8, and 1.0 kGy. Samples that were exposed to 0.0, 1.0, and 1.5 kGy and kept under refrigeration (4°C) for 12 days were submitted to sensory analysis. D10 -values ranged from 0.19 to 0.20 kGy for Salmonella and from 0.20 to 0.21 for L. monocytogenes; for STEC, the value was 0.17 kGy. Spinach showed good acceptability, even after exposure to 1.5 kGy. Because gamma radiation reduced the selected pathogens without causing significant changes in the quality of spinach leaves, it may be a useful method to improve safety in the fresh produce industry.

Assuntos

RESUMO

Listeria monocytogenes is a foodborne pathogen of great concern due to the high fatality rates of listeriosis. The consumption of RTE vegetables has increased in Brazil over the last two decades, but little is known about the risks associated to the consumption of these products. This study evaluated the prevalence and counts of L. monocytogenes in 512 packages of ready-to-eat vegetables marketed in São Paulo. The isolates were characterized for their serotypes, ribotypes, positivity for virulence genes inlA, inlC and inlJ, resistance to chlorine, growth rate variability and capability to form biofilm on stainless steel (AISI 304, #4) coupons. L. monocytogenes was detected in 3.1% of the samples. Only five samples presented countable levels, with counts between 1.0×10(1) and 2.6×10(2)CFU/g. Isolates belonged to serotypes 1/2b or 4b and most were positive for genes inlC and inlJ. Ribotypable isolates were grouped into four groups: 1038 (69.4%), 19175 (11.3%), 19191 (17.7%) and 18604 (one isolate). Most isolates survived to exposure to 125 ppm of a chlorine-based disinfectant for 3 min. All isolates were capable to attach to the coupons, reaching counts above 4 log(10) CFU/cm(2) and the growth rate (µ) at 25°C of the majority of the isolates varied between 0.1 and 0.2 log OD/h, but for few strains the µ was as high as 0.26 log OD/h. Results of this survey indicate that RTE vegetables may be vehicles of L. monocytogenes strains with limited variation in serotype, ribotype and virulence factors but varying significantly in resistance to chlorine disinfectants, capability of forming biofilm and growth rate. Data obtained is of foremost importance to serve as baseline for the development of scientific-based policies to control the incidence of L. monocytogenes in RTE vegetables in Brazil.

Assuntos