RESUMEN

The management of produced water (PW) generated during oil and gas operations requires effective treatment and comprehensive chemical and toxicological assessment to reduce the environmental risks associated with reuse or discharge. This study evaluated a treatment train that included a low-temperature thermal distillation pilot system followed by granular activated carbon (GAC) and zeolite post-treatment for processing hypersaline Permian Basin PW. Our study provides a unique and comprehensive assessment of the treatment efficiency considering a targeted chemical scheme together with whole effluent toxicity (WET) tests across four trophic levels regarding aquatic critical receptors of concern (ROC): Raphidocelis subcapitata, Vibrio fischeri, Ceriodaphnia dubia, and Danio rerio. The distillate from the thermal distillation process met various numeric discharge standards for salinity and major ions. However, it did not meet toxicity requirements established by the United States National Pollutant Discharge Elimination System program. Subsequent post-treatment using GAC and zeolite reduced the concentration of potential stressors, including volatile organics, NH3, Cd, Cr, Zn, and Mn in the final effluent to below detection limits. This resulted in a consistent toxicity reduction across all WET tests, with no observable adverse effects for R. subcapitata, C. dubia, and D. rerio (no observed effect concentration >100%), and V. fischeri effects reduced to 19%. This study realizes the feasibility of treating PW to non-toxic levels and meeting reuse and discharge requirements. It underscores the importance of implementing integrated treatment trains to remove the contaminants of concern and provides a systematic decision framework to predict and monitor environmental risks associated with PW reuse.

Asunto(s)

RESUMEN

Resumo Este trabalho teve como objetivo avaliar as remoções de carbono orgânico dissolvido presente em águas filtradas de estação de tratamento de água com tratamento complementar por pré-oxidação com ozônio e adsorção em carvão ativado granular. Para o estudo de adsorção foi utilizado o método de ensaio rápido em coluna de escala reduzida, com carvão ativado produzido de cascas de coco. Realizou-se a comparação entre as curvas de ruptura para os ensaios com e sem aplicação de ozônio. Os resultados mostraram reduções nas concentrações de carbono orgânico dissolvido no início dos ensaios e após a passagem da água com e sem pré-ozonização pelas colunas ensaio rápido em coluna de escala reduzida seguida de incrementos progressivos das concentrações à medida que se aumentou o volume de leitos tratados. Na fase final dos ensaios, os aumentos de volume de leitos tratados não causaram mudanças significativas nas concentrações efluentes de carbono orgânico dissolvido. O mesmo comportamento foi observado com relação à absorção em radiação ultravioleta a 254 nm. O uso de ozônio previamente à adsorção em carvão ativado granular, usando o método ensaio rápido em coluna de escala reduzida, resultou em maiores reduções na absorbância da luz ultravioleta em 254 nm do que nas concentrações de carbono orgânico dissolvido. As absorbâncias específicas à radiação ultravioleta das amostras ozonizadas foram menores do que as que não receberam ozônio.

Abstract The objective of this study was to evaluate the removal of dissolved organic carbon in filtered water followed by pre-oxidation with ozone and adsorption on granular activated carbon. The rapid small-scale column test was used for the adsorption essays with activated carbon produced from coconut shells. A comparison was made between the breakthrough curves for tests performed with and without pre-oxidation with ozone. The results showed reductions in dissolved organic carbon concentrations after initial passage of water with and without ozone through the rapid small-scale column test column, followed by progressive increases in concentrations along with the number of the bed volumes. In the final phase of the tests, increases in bed volumes did not cause significative changes in effluent dissolved organic carbon concentrations. The same behavior was also observed with respect to ultra-violet absorbance at 254 nm. The use of ozone prior to adsorption on GAC, using the ERCER method, caused greater reductions on UV254 absorbance than in concentrations of dissolved organic carbon. The specific ultraviolet absorbance values of samples that received ozone were lower than those that were not ozonized.

RESUMEN

This study measured chlorine- and chloramine-reactive precursors using formation potential (FP) tests of nine U.S. Environmental Protection Agency (EPA) regulated and 57 unregulated disinfection byproducts (DBPs) in tertiary-filtered wastewater before and after pilot-scale granular activated carbon (GAC) adsorption. Using breakthrough of precursor concentration and of concentration associated calculated cytotoxicity and genotoxicity (by correlating known lethal concentrations reported elsewhere), the performance of three parallel GAC treatment trains were compared against tertiary-filtered wastewater: ozone/GAC, chlorine/GAC, and GAC alone. Results show GAC alone was the primary process, versus ozone or chlorine alone, to remove the largest fraction of total chlorine- and chloramine-reactive DBP precursors and calculated cytotoxicity and genotoxicity potencies. GAC with pre-ozonation removed the most chlorine- and chloramine-reactive DBP precursors followed by GAC with pre-chlorination and lastly GAC without pre-treatment. GAC with pre-ozonation produced an effluent with cytotoxicity and genotoxicity of DBPs from FP that generally matched that of GAC without pre-oxidation; meanwhile removal of toxicity was greater by GAC with pre-chlorination. The cytotoxicity and genotoxicity of DBPs from FP tests did not scale with DBP concentration; for example, more than 90% of the calculated cytotoxicity resulted from 20% of the DBPs, principally from haloacetaldehydes, haloacetamides, and haloacetonitriles. The calculated cytotoxicity and genotoxicity from DBPs associated with FP-chloramination were at times higher than with FP-chlorination though the concentration of DBPs was five times higher with FP-chlorination. The removal of DBP precursors using GAC based treatment was at least as effective as removal of DOC (except for halonitromethanes for GAC without pre-oxidation and with pre-chlorination), indicating DOC can be used as an indicator for DBP precursor adsorption efficacy. However, the DOC was not a good surrogate for total cytotoxicity and genotoxicity breakthrough behavior, therefore, unregulated DBPs could have negative health implications that are disconnected from general water quality parameters, such as DOC, and regulated classes of DBPs. Instead, cytotoxicity and genotoxicity correlate with the concentration of specific classes of unregulated DBPs.

RESUMEN

Perfluoroalkyl acids (PFAAs) are of concern because of their persistence in the environment and the potential toxicological effects on humans exposed to PFAAs through a variety of possible exposure routes, including contaminated drinking water. This study evaluated the efficacy of nanofiltration (NF) and granular activated carbon (GAC) adsorption in removing a suite of PFAAs from water. Virgin flat-sheet NF membranes (NF270, Dow/Filmtec) were tested at permeate fluxes of 17-75 Lm(-2)h(-1) using deionized (DI) water and artificial groundwater. The effects of membrane fouling by humic acid on PFAA rejection were also tested under constant permeate flux conditions. Both virgin and fouled NF270 membranes demonstrated >93% removal for all PFAAs under all conditions tested. GAC efficacy was tested using rapid small-scale columns packed with Calgon Filtrasorb300 (F300) carbon and DI water with and without dissolved organic matter (DOM). DOM effects were also evaluated with F600 and Siemens AquaCarb1240C. The F300 GAC had <20% breakthrough of all PFAAs in DI water for up to 125,000 bed volumes (BVs). When DOM was present, >20% breakthrough of all PFAAs by 10,000 BVs was observed for all carbons.

Asunto(s)