RESUMEN

This work explored the impact of ultrasound (US) on the activity, stability, and macrostructural conformation of cyclodextrin glycosyltransferase (CGTase) and how these changes could maximize the production of ß-cyclodextrins (ß-CDs). The results showed that ultrasonic pretreatment (20 kHz and 38 W/L) at pH 6.0 promoted increased enzymatic activity. Specifically, after sonication at 25 °C/30 min, there was a maximum activity increase of 93 % and 68 % when biocatalysis was carried out at 25 and 55 °C, respectively. For activity measured at 80 °C, maximum increase (31 %) was observed after sonication at 25 °C/60 min. Comparatively, US pretreatment at low pH (pH = 4.0) resulted in a lower activity increase (max. 28 %). These activation levels were maintained after 24 h of storage at 8 °C, suggesting that changes on CGTase after ultrasonic pretreatment were not transitory. These pretreatments altered the conformational structure of CGTase, revealed by an up to 11 % increase in intrinsic fluorescence intensity, and resulted in macrostructural modifications, such as a decrease in particle size and polydispersion index (up to 85 % and 45.8 %, respectively). Therefore, the sonication of CGTase under specific conditions of pH, time, and temperature (especially at pH 6.0/ 30 min/ 25 °C) promotes macrostructural changes in CGTase that induce enzyme activation and, consequently, higher production of ß-CDs.

Asunto(s)

RESUMEN

Glycoside hydrolases (GH) are enzymes capable to hydrolyze the glycosidic bond between two carbohydrates or even between a carbohydrate and a non-carbohydrate moiety. Because of the increasing interest for industrial applications of these enzymes, the immobilization of GH has become an important development in order to improve its activity, stability, as well as the possibility of its reuse in batch reactions and in continuous processes. In this review, we focus on the broad aspects of immobilization of enzymes from the specific GH families. A brief introduction on methods of enzyme immobilization is presented, discussing some advantages and drawbacks of this technology. We then review the state of the art of enzyme immobilization of families GH1, GH13, and GH70, with special attention on the enzymes ß-glucosidase, α-amylase, cyclodextrin glycosyltransferase, and dextransucrase. In each case, the immobilization protocols are evaluated considering their positive and negative aspects. Finally, the perspectives on new immobilization methods are briefly presented.

Asunto(s)

RESUMEN

Cyclodextrin glycosyltransferases (CGTase) are reported to selectively catalyze α(1 → 4)-glycosyl transfer reactions besides showing low hydrolytic activity. Here, the effect of the anomeric configuration of the glycosyl acceptor on the regioselectivity of CGTase catalyzed glycosylations was investigated. For this purpose, the α and ß anomers of p-nitrophenyl-D-glucopyranoside were used as glycosyl acceptors, Bacillus macerans and Thermoanaerobacter sp. CGTases were used as biocatalysts and ß-cyclodextrin as the glycosyl donor. As expected, p-nitrophenyl-α-D-glucopyranosyl-(1 → 4)-O-α-D-glucopyranoside was produced when p-nitrophenyl-α-D-glucopyranoside was used as acceptor with B. macerans CGTase. Surprisingly, when p-nitrophenyl-ß-D-glucopyranoside was used as glycosyl acceptor, besides the expected α(1 → 4)-glycosylation products both α(1 → 3)- and α(1 → 6)-transfer products were also obtained. This unexpected change in B. macerans CGTase regioselectivity leading to α(1 → 4)-, α(1 → 3)- and α(1 → 6)-glycosylation products was also observed for Thermoanaerobacter sp. CGTase with the ß anomer. It is shown, applying time course analyses, that all isomers can be synthesized efficiently by adequate selection of enzyme and reaction conditions. In fact, when using Thermoanaerobacter sp. CGTase the yield of p-nitrophenyl-ß-D-isomaltoside (the α(1 → 6)-transfer product) was the highest at long reaction time (19% yield). The previously unknown capacity of α(1 → 6)-glycosidic linkages formation by CGTases demonstrates an unexpected broader regioselectivity of CGTases in glycosyl-transfer reactions as well as an acceptor dependent transfer selectivity.

Asunto(s)

RESUMEN

Background: Cyclodextrin glucanotransferase (CGTase) is one of the most industrially important enzymes used in the commercial production of cyclodextrins (CDs). Alkaliphilic bacteria have attracted much interest in the last few decades because of their ability to produce extracellular enzymes that are active and stable at high pH values. Here, we report the isolation of a new CGTase from alkaliphilic bacteria collected from Egyptian soda lakes and describe the purification and biochemical characterization of this CGTase. Results: Screening for CGTase-producing alkaliphilic bacteria from sediment and water samples collected from Egyptian soda lakes located in the Wadi Natrun valley resulted in the isolation of a potent CGTase-producing alkaliphilic bacterial strain, designated NRC-WN. Strain NRC-WN was belonging to genus Amplibacullus by 16S rDNA sequence analysis (similarity: ca. 98%). Among the tested nitrogen and carbon sources, peptone (0.15%, w/v) and soluble starch (0.4%, w/v) allowed maximal CGTase production by Amphibacillus sp. NRC-WN. CGTase was successfully purified from Amphibacillus sp. NRC-WN up to 159.7-fold through a combination of starch adsorption and anion exchange chromatography, resulting in a yield of 84.7%. SDS-PAGE analysis indicated that the enzyme was purified to homogeneity and revealed an estimated molecular mass of 36 kDa, which makes it one of the smallest CGTases reported in the literature. The purified enzyme exhibited maximum activity at 50ºC and was stable up to 70ºC, retaining 93% of its initial activity after treatment for 1 hr. Furthermore, Ca2+ ions (10 mM) significantly enhanced the thermal stability of the CGTase. The purified enzyme was active and stable over a wide pH range, showing maximal activity at pH 9.5. The enzyme was significantly stimulated by Zn2+, Ca2+ and Co2+ but was completely inhibited in the presence of Fe3+ and mercaptoethanol. The Km and Vmax values of the purified CGTase were estimated to be 0.0434 mg/ml and 3,333.3 mg β-CD/ml/min, respectively. β-CD was the predominant product of starch degradation by the Amphibacillus sp. NRC-WN CGTase, followed by α-and γ-CDs. Conclusions: A new low molecular mass alkaline CGTase was purified from a newly identified alkaliphilic Amphibacillus sp. NRC-WN isolate from the Egyptian soda lakes. The enzyme showed promising thermal and pH stability and a high affinity toward starch as a natural substrate.

Asunto(s)

RESUMEN

Cyclodextrin glycosyltransferase (CGTase) from Thermoanaerobacter sp. was covalently immobilized on glutaraldehyde-activated chitosan spheres and used in a packed bed reactor to investigate the continuous production of ß-cyclodextrin (ß-CD). The optimum temperatures were 75 °C and 85 °C at pH 6.0, respectively for free and immobilized CGTase, and the optimum pH (5.0) was the same for both at 60 °C. In the reactor, the effects of flow rate and substrate concentration in the ß-CD production were evaluated. The optimum substrate concentration was 4% (w/v), maximizing the ß-CD production (1.32 g/L) in a flow rate of 3 mL/min. In addition, the biocatalyst had good operational stability at 60 °C, maintaining 61% of its initial activity after 100 cycles of batch and 100% after 100 h of continuous use. These results suggest the possibility of using this immobilized biocatalyst in continuous production of CDs.

Asunto(s)

RESUMEN

Three strains of Bacillus sp. (BACRP, BACNC-1 and BACAR) were isolated from soil adhered to cassava husk. CGTase specific activity for the three isolated strains was higher when cultivated at 40¨¬C. Potato starch, cassava starch, maltodextrin and glucose were used as carbon source and growth temperatures varied from 25 to 55¨¬C. The three isolates presented higher CGTase specific activity when cultivated with potato starch at 40¨¬C. Isolated BACRP and BACAR presented specific activity of 4.0x10-3 and 2.2x10-3 U/mg prot at pH 7.0, respectively, when cultivated in mediums added with NaCl 2 percent; at pH 10,0 their activities were of 3.4x10-3 and 3.0x10-3 U/mg prot, respectively, in the same concentration of NaCl. On the other hand, the isolated BACNC-1 presented activity specific of 2.4x10-3 U/mg prot when cultivated at pH 7.0 added of NaCl 1 percent, and at pH 10.0 the specific activity was of 3.4x10-3 U/mg prot without NaCl addition. This work also showed the presence of cyclodextrins formed during fermentation process and that precipitation with acetone or lyophilization followed by dialysis was efficient at removing CDs (cyclodextrins), thus, eliminating interference in the activity assays. The enzyme produced by the BACAR strain was partially purified and ¥â-CD was liberated as a reaction product.

Três linhagens de Bacillus sp (BACRP, BACNC- 1 e BACAR) foram isoladas a partir de solo aderido em casca de mandioca. Foram utilizados amido de batata, amido de mandioca, maltodextrina e glicose como fonte de carbono, e temperaturas de crescimento de 25-55¨¬C, sendo que os três isolados apresentaram maior atividade específica de CGTase quando cultivados com amido de batata a 40¨¬C. Em pH 7,0 os isolados BACRP e BACAR apresentaram atividade específica de 4,0x 10-3 e 2,2x10-3 U/mg prot, respectivamente, quando cultivados em meios acrescidos de 2 por cento de NaCl; em pH 10,0 suas atividades foram de 3,4x10-3 e 3,0x10-3 U/mg prot na mesma concentração de NaCl. Por outro lado, o isolado de BACNC-1 apresentou atividade específica 2,4x10-3 U/mg prot quando cultivado em pH 7,0 acrescido de 1 por cento de NaCl, e em pH 10,0 sua atividade específica foi de 3,4x10-3 U/mg prot sem adição de NaCl. Também foi demonstrada neste trabalho que ciclodextrinas são formadas durante o processo fermentativo, e que a precipitação com acetona ou liofilização seguida de diálise foram eficientes na remoção destas CDs, eliminando sua interferência nos ensaios enzimáticos. A enzima produzida pela cepa BACAR foi purificada parcialmente liberando b-CD como produto da reação.

Asunto(s)

RESUMEN

Three strains of Bacillus sp. (BACRP, BACNC-1 and BACAR) were isolated from soil adhered to cassava husk. CGTase specific activity for the three isolated strains was higher when cultivated at 40°C. Potato starch, cassava starch, maltodextrin and glucose were used as carbon source and growth temperatures varied from 25 to 55°C. The three isolates presented higher CGTase specific activity when cultivated with potato starch at 40°C. Isolated BACRP and BACAR presented specific activity of 4.0×10(-3) and 2.2×10(-3) U/mg prot at pH 7.0, respectively, when cultivated in mediums added with NaCl 2%; at pH 10,0 their activities were of 3.4×10(-3) and 3.0×10(-3) U/mg prot, respectively, in the same concentration of NaCl. On the other hand, the isolated BACNC-1 presented activity specific of 2.4×10(-3) U/mg prot when cultivated at pH 7.0 added of NaCl 1%, and at pH 10.0 the specific activity was of 3.4×10(-3) U/mg prot without NaCl addition. This work also showed the presence of cyclodextrins formed during fermentation process and that precipitation with acetone or lyophilization followed by dialysis was efficient at removing CDs (cyclodextrins), thus, eliminating interference in the activity assays. The enzyme produced by the BACAR strain was partially purified and ß-CD was liberated as a reaction product.

RESUMEN

Three strains of Bacillus sp. (BACRP, BACNC-1 and BACAR) were isolated from soil adhered to cassava husk. CGTase specific activity for the three isolated strains was higher when cultivated at 40ºC. Potato starch, cassava starch, maltodextrin and glucose were used as carbon source and growth temperatures varied from 25 to 55ºC. The three isolates presented higher CGTase specific activity when cultivated with potato starch at 40ºC. Isolated BACRP and BACAR presented specific activity of 4.0x10-3 and 2.2x10-3 U/mg prot at pH 7.0, respectively, when cultivated in mediums added with NaCl 2%; at pH 10,0 their activities were of 3.4x10-3 and 3.0x10-3 U/mg prot, respectively, in the same concentration of NaCl. On the other hand, the isolated BACNC-1 presented activity specific of 2.4x10-3 U/mg prot when cultivated at pH 7.0 added of NaCl 1%, and at pH 10.0 the specific activity was of 3.4x10-3 U/mg prot without NaCl addition. This work also showed the presence of cyclodextrins formed during fermentation process and that precipitation with acetone or lyophilization followed by dialysis was efficient at removing CDs (cyclodextrins), thus, eliminating interference in the activity assays. The enzyme produced by the BACAR strain was partially purified and -CD was liberated as a reaction product.

Três linhagens de Bacillus sp (BACRP, BACNC- 1 e BACAR) foram isoladas a partir de solo aderido em casca de mandioca. Foram utilizados amido de batata, amido de mandioca, maltodextrina e glicose como fonte de carbono, e temperaturas de crescimento de 25-55ºC, sendo que os três isolados apresentaram maior atividade específica de CGTase quando cultivados com amido de batata a 40ºC. Em pH 7,0 os isolados BACRP e BACAR apresentaram atividade específica de 4,0x 10-3 e 2,2x10-3 U/mg prot, respectivamente, quando cultivados em meios acrescidos de 2% de NaCl; em pH 10,0 suas atividades foram de 3,4x10-3 e 3,0x10-3 U/mg prot na mesma concentração de NaCl. Por outro lado, o isolado de BACNC-1 apresentou atividade específica 2,4x10-3 U/mg prot quando cultivado em pH 7,0 acrescido de 1% de NaCl, e em pH 10,0 sua atividade específica foi de 3,4x10-3 U/mg prot sem adição de NaCl. Também foi demonstrada neste trabalho que ciclodextrinas são formadas durante o processo fermentativo, e que a precipitação com acetona ou liofilização seguida de diálise foram eficientes na remoção destas CDs, eliminando sua interferência nos ensaios enzimáticos. A enzima produzida pela cepa BACAR foi purificada parcialmente liberando b-CD como produto da reação.

RESUMEN

Cyclodextrin glycosyltransferase (EC 2.4.1.19) is an enzyme that produces cyclodextrins from starch via an intramolecular transglycosylation reaction. An alkalophilic Bacillus strain, isolated from cassava peels, was identified as Bacillus licheniformis. CGTase production by this strain was better when potato starch was used as carbon source, followed by cassava starch and amylopectin. Glucose and amylose, on the other hand, acted as synthesis repressors. When the cultivation was supplemented with sodium ions and had the pH adjusted between 6.0 and 9.0, the microorganism maintained the growth and enzyme production capacity. This data is interesting because it contradicts the concept that alkalophilic microorganisms do not grow in this pH range. After ultrafiltration-centrifugation, one protein of 85.2 kDa with CGTase activity was isolated. This protein was identified in plates with starch and phenolphthalein. Determination of the optimum temperature showed higher activities at 25ºC and 55ºC, indicating the possible presence of more than one CGTase in the culture filtrate. Km and Vmax values were 1.77 mg/mL and 0.0263 U/mg protein, respectively, using potato starch as substrate.

Ciclodextrina glicosiltransferase (EC 2.4.1.19) é uma enzima que produz ciclodextrinas a partir de amido via transglicosilação intramolecular. Uma cepa de Bacillus alcalofílico, isolada de cascas de mandioca, foi identificada como Bacillus licheniformis. A produção de CGTase por esta cepa foi melhor quando amido de batata foi utilizado como fonte de carbono, seguido por amido de mandioca e amilopectina. Glicose e amilose, por outro lado, atuaram como repressor de síntese desta enzima. Quando o cultivo foi suplementado com íons sódio e teve o pH ajustado entre 6,0 e 9,0, o microrganismo manteve a capacidade de crescimento e de produção da enzima. Este dado é interessante pois contraria o conceito de que microrganismos alcalofílicos não apresentam crescimento nesta faixa de pH. Após ultrafiltração-centrifugação, uma proteína de 85,2 kDa com atividade de CGTase foi isolada. Esta proteína foi identificada em placas contendo amido e fenolftaleína. A determinação da temperatura ótima mostrou atividades mais elevadas em 25ºC e 55ºC, indicando a possível presença de mais de uma CGTase no filtrado de cultura. Valores de Km e Vmax foram 1,77 mg/mL e 0,0263 U/mg proteína, respectivamente, usando amido de batata como substrato.