RESUMEN
In this study, we assess the feasibility of using Fourier Transform Infrared Photoacoustic Spectroscopy (FTIR-PAS) to predict macro- and micro-nutrients in a diverse set of manures and digestates. Furthermore, the prediction capabilities of FTIR-PAS were assessed using a novel error tolerance-based interval method in view of the accuracy required for application in agricultural practices. Partial Least-Squares Regression (PLSR) was used to correlate the FTIR-PAS spectra with nutrient contents. The prediction results were then assessed with conventional assessment methods (root mean square error (RMSE), coefficient of determination R2, and the ratio of prediction to deviation (RPD)). The results show the potential of FTIR-PAS to be used as a rapid analysis technique, with promising prediction results (R2 > 0.91 and RPD >2.5) for all elements except for bicarbonate-extractable P, K, and NH4+-N (0.8 < R2 < 0.9 and 2 < RPD <2.5). The results for nitrogen and phosphorus were further evaluated using the proposed error tolerance-based interval method. The probability of prediction for nitrogen within the allowed limit is calculated to be 94.6 % and for phosphorus 83.8 %. The proposed error tolerance-based interval method provides a better measure to decide if the FTIR-PAS in its current state could be used to meet the required accuracy in agriculture for the quantification of nutrient content in manure and digestate.
RESUMEN
Using bio-based fertilizer (BBF) in agricultural soil can reduce the dependency on chemical fertilizer and increase sustainability by recycling nutrient-rich side-streams. However, organic contaminants in BBFs may lead to residues in the treated soil. This study assessed the presence of organic contaminants in BBF treated soils, which is essential for evaluating sustainability/risks of BBF use. Soil samples from two field studies amended with 15 BBFs from various sources (agricultural, poultry, veterinary, and sludge) were analyzed. A combination of QuEChERS-based extraction, liquid chromatography quadrupole time of flight mass spectrometry-based (LC-QTOF-MS) quantitative analysis, and an advanced, automated data interpretation workflow was optimized to extract and analyze organic contaminants in BBF-treated agricultural soil. The comprehensive screening of organic contaminants was performed using target analysis and suspect screening. Of the 35 target contaminants, only three contaminants were detected in the BBF-treated soil with concentrations ranging from 0.4 ng g-1 to 28.7 ng g-1; out of these three detected contaminants, two were also present in the control soil sample. Suspect screening using patRoon (an R-based open-source software platform) workflows and the NORMAN Priority List resulted in tentative identification of 20 compounds (at level 2 and level 3 confidence level), primarily pharmaceuticals and industrial chemicals, with only one overlapping compound in two experimental sites. The contamination profiles of the soil treated with BBFs sourced from veterinary and sludge were similar, with common pharmaceutical features identified. The suspect screening results suggest that the contaminants found in BBF-treated soil might come from alternative sources other than BBFs.
Asunto(s)
Fertilizantes , Aguas del Alcantarillado , Fertilizantes/análisis , Aguas del Alcantarillado/análisis , Suelo , Cromatografía Liquida/métodos , Espectrometría de Masas/métodosRESUMEN
The integration of biological nitrogen (N) removal with struvite-type material recovery, which contained phosphorus (P) and potassium (K), was proved to be technically feasible in pig slurry treatment. Phosphate (PO4) salts were precipitated by raising the pH-value, using denitrified effluent and waste sludge purged from the bioreactor. When P was limiting, the unbalanced composition of the denitrified effluent resulted in low K-removal efficiency from the liquid phase; 10 % maximum when the initial pH-value was adjusted to 11.5 (93 % PO4-P recovery). By processing the waste sludge in two steps, using first ethylenediaminetetraacetic acid (EDTA) as an acidifier to release PO4 while preventing calcium interference, the K-removal efficiency reached 25 % (75 % PO4-P recovery). When K was limiting, the addition of newberyite particles resulted in the highest K-removal efficiency, up to 90 % (under online pH control to 10.5). Overall, new opportunities are envisaged for producing second-generation fertilizers potentially containing 0-1 % N, 11-17 % P and 6-8 % K.
Asunto(s)
Nitrificación , Aguas del Alcantarillado , Animales , Calcio , Desnitrificación , Ácido Edético , Fertilizantes/análisis , Nitrógeno/análisis , Fosfatos/química , Fósforo/química , Potasio , Sales (Química) , Aguas del Alcantarillado/química , Estruvita/química , Porcinos , Eliminación de Residuos Líquidos/métodosRESUMEN
The use of phosphate rocks as low-solubility phosphorus fertilizers has been promoted to reduce the environmental impacts of agriculture, but adequate nutrient uptake by plants depends on solubilization of the rock, driven by soil microorganisms. Here, investigation was made of the microbial solubilization of low-solubility phosphate rocks, together with simultaneous bioprotective action involving the biocontrol of microorganisms. The aim was to enhance function and value by delivering two effects using a single bio-based product, in accordance with the concept of a "bioreactor-in-a-granule" system. A composite structure was developed, based on a starch matrix, comprising a combination of Trichoderma asperelloides, as a biocontrol agent, and Aspergillus niger, as an acidulant. A significant increase of up to 150% in P solubilization was achieved, indicating the positive effect of the microorganism-composite interaction. In vitro assays showed that the ability of T. asperelloides to inhibit Fusarium oxysporum mycelial growth was maintained in the presence of A. niger. Moreover, the estimated cost of the composite granule (0.35 US$/kg of product on a dry basis) revealed competitive. The results indicated that the association of T. asperelloides and A. niger is an effective way to increase nutrient availability and to inhibit plant pathogens, opening up possibilities for the design of multifunctional bio-based fertilizer composites.