RESUMEN
Anaerobic digestion of poultry litter is a potentially sustainable means of stabilizing this waste while generating biogas. However, technical challenges remain including seasonality of litter production, low C/N ratios, limited digestibility of bedding, and questions about transformation of nutrients during digestion. This study investigated biogas production and nutrient transformations during anaerobic digestion of poultry litter leachate and whole litter. Use of fresh litter collected from within the house was also compared to waste litter cake that was stored outdoors on the farm. The results showed that litter leachates had higher biomethane potential (0.24-0.30â¯L/gVS) than whole litter (0.15-0.16â¯L/gVS) and the insoluble bedding material left after leaching (0.08-0.13â¯L/gVS). Leachates prepared from waste litter cake had lower uric acid and higher acetic acid concentrations than fresh litter indicating that decomposition had occurred during storage. Consequently, waste litter cake had faster initial biogas production but lower final biogas yields compared to fresh litter. In all reactors, uric and acetic acids were completely consumed during digestion, phosphate levels decreased but ammonium levels increased. The results demonstrate that poultry litter leachate is amenable to digestion despite a low C/N ratio and that the remaining insoluble bedding material has been partially stripped of its nutrients. Moreover, litter can be stored prior to digestion but some losses in biomethane potential should be expected due to decomposition of organics during storage.
Asunto(s)
Biocombustibles , Aves de Corral , Anaerobiosis , Animales , Reactores Biológicos , Metano , NutrientesRESUMEN
Hydrothermal liquefaction (HTL) of nine algae species were performed at two reaction temperatures (280 and 320°C) to compare the effect of their biomass composition on product yields and properties. Results obtained after HTL indicate large variations in terms of bio-oil yields and its properties. The maximum bio-oil yield (66wt%) was obtained at 320°C with a high lipid containing algae Nannochloropsis. The higher heating value of bio-oils ranged from 31 to 36MJ/kg and around 50% of the bio-oils was in the vacuum gas oil range while high lipid containing algae Nannochloropsis contained a significant portion (33-42%) in the diesel range. A predictive relationship between bio-oil yields and biochemical compositions was developed and showed a broad agreement between predictive and experimental yields. The aqueous phases obtained had high amount of TOC (12-43g/L), COD (35-160g/L), TN (1-18g/L), ammonium (0.34-12g/L) and phosphate (0.7-12g/L).
Asunto(s)
Biocombustibles , Chlorophyta , Biomasa , Cromatografía de Gases y Espectrometría de Masas , Aceites , TemperaturaRESUMEN
Removal of nutrients (phosphorus and nitrogen) as struvite from bio-oil aqueous phase generated via hydrothermal liquefaction of algae was evaluated in this study. Effect of process parameters such as pH, temperature and reaction time on struvite formation was studied. More than 99% of phosphorus and 40-100% ammonium nitrogen were removed under all experimental conditions. X-ray diffraction analysis confirmed the formation of struvite, and the struvite recovered from bio-oil aqueous phase can be used as a slow-release fertilizer. Biogas production from struvite recovered bio-oil aqueous phase showed 3.5 times higher CH4 yield (182±39mL/g COD) as compared to non-struvite recovered aqueous phase. The results from this study indicate that both struvite and methane can be produced from bio-oil aqueous phase.
Asunto(s)
Biocombustibles , Biotecnología/métodos , Microalgas/metabolismo , Nitrógeno/aislamiento & purificación , Fósforo/aislamiento & purificación , Aceites de Plantas/química , Temperatura , Agua/química , Compuestos de Amonio/análisis , Anaerobiosis , Análisis de la Demanda Biológica de Oxígeno , Biotecnología/economía , Fertilizantes , Metano/análisis , Fosfatos/análisis , Estruvita/análisis , Aguas Residuales/químicaRESUMEN
Hydrothermal liquefaction of wet biomass such as algae is a promising thermochemical process for the production of bio-oil. Bio-oil aqueous phase generated during liquefaction process is rich in complex organics and can be utilized for biogas production following its pre-treatment with granular activated carbon. In our study, use of 30% activated carbon resulted in higher chemical oxygen demand (COD) reduction (53±0.3%) from aqueous phase. Higher CH4 production (84±12mL/gCOD) was also observed in 30% carbon-treated aqueous phase fed cultures, whereas only 32±6mLCH4/gCOD was observed in control (non-carbon treated) cultures. The results from this study indicate that almost 67±0.3% initial COD of aqueous phase can be reduced using a combination of both carbon treatment and biogas production. This study shows that aqueous phase can be utilized for CH4 production.