RESUMEN
Commercial and pilot pectate lyase preparations (EC 4.2.2.2) have been compared. They differ in their effect on pectins with different esterification degrees (ED). The activity of the pilot preparation with respect to a substrate with ED = 70% is tenfold lower than with respect to unesterified polygalacturonic acid. For commercial preparations, this activity ratio ranged within 1.5-2. At equal pectate lyase activities, the commercial preparations better remove pectin from crude cotton fabric during its boil off. The laboratory preparation is more efficient for improving the capillarity (wettability) of the fabric owing to the cooperative effect of the pectate lyase, cellulase, and hemicellulase present in the preparation.
Asunto(s)
Bacillus/enzimología , Proteínas Bacterianas/química , Fibra de Algodón/métodos , Polisacárido Liasas/química , Proteínas Bacterianas/aislamiento & purificación , Polisacárido Liasas/aislamiento & purificaciónRESUMEN
Using different chromatographic techniques, eight cellulolytic enzymes were isolated from the culture broth of a mutant strain of Chrysosporium lucknowense: six endoglucanases (EG: 25 kD, pI 4.0; 28 kD, pI 5.7; 44 kD, pI 6.0; 47 kD, pI 5.7; 51 kD, pI 4.8; 60 kD, pI 3.7) and two cellobiohydrolases (CBH I, 65 kD, pI 4.5; CBH II, 42 kD, pI 4.2). Some of the isolated cellulases were classified into known families of glycoside hydrolases: Cel6A (CBH II), Cel7A (CBH I), Cel12A (EG28), Cel45A (EG25). It was shown that EG44 and EG51 are two different forms of one enzyme. EG44 seems to be a catalytic module of an intact EG51 without a cellulose-binding module. All the enzymes had pH optimum of activity in the acidic range (at pH 4.5-6.0), whereas EG25 and EG47 retained 55-60% of the maximum activity at pH 8.5. Substrate specificity of the purified cellulases against carboxymethylcellulose (CMC), beta-glucan, Avicel, xylan, xyloglucan, laminarin, and p-nitrophenyl-beta-D-cellobioside was studied. EG44 and EG51 were characterized by the highest CMCase activity (59 and 52 U/mg protein). EG28 had the lowest CMCase activity (11 U/mg) amongst the endoglucanases; however, this enzyme displayed the highest activity against beta-glucan (125 U/mg). Only EG51 and CBH I were characterized by high adsorption ability on Avicel cellulose (98-99%). Kinetics of Avicel hydrolysis by the isolated cellulases in the presence of purified beta-glucosidase from Aspergillus japonicus was studied. The hydrolytic efficiency of cellulases (estimated as glucose yield after a 7-day reaction) decreased in the following order: CBH I, EG60, CBH II, EG51, EG47, EG25, EG28, EG44.