RESUMEN

Bacterial viruses known as bacteriophages have been demonstrated to be effective in killing foodborne pathogens such as Shigella flexneri. Adsorption is the first step in the phage-host interaction. In the present work, 10 Shigella phages were used to characterize the adsorption process on Shigella flexneri ATCC12022 in several physicochemical conditions related to food and in a food matrix. One-step growth curves were drawn for all the Shigella-phages evaluated. Furthermore, the adsorption rate for each of the 10 phages was determined. In addition, the influence of temperature, Na+, Mg2+, pH, sucrose and glycerol on phage adsorption was investigated. Two phages (Shi22 and Shi30) showed higher burst sizes values (67 and 64 PFU cell-1, respectively) and burst times of 25 min to 30 min, while the other eight phages exhibited burst sizes ranging from 14 to 17 PFU cell-1 with slower burst times. Furthermore, most phages achieved a high adsorption rate, and the adsorption constants (k) ranged from ~10-9 to 10-10 mL min-1. Regarding the influence of temperature, cations and pH, a high or moderate percentage of adsorption was observed for most of the phages evaluated. The adsorption decreased at increasing concentrations of Na+, sucrose and glycerol, although at different levels, since adsorption was more affected by sucrose than by glycerol and Na+ for most phages. The adsorption obtained in Triptein soy broth (TSB) for most of the phages/strain systems evaluated was moderate or high, as well as those observed in a food matrix. Thus, our phages could potentially be used to improve food safety under a wide range of environmental conditions against foodborne pathogens.

Asunto(s)

RESUMEN

Fifteen samples of whey protein concentrate (WPC) were tested against 37 commercial Streptococcus thermophilus strains to detect infective bacteriophages. Seventy-three diverse phages were isolated from 12 samples, characterized by using DNA restriction patterns and host range analyses. Sixty-two of them were classified as cos, two as pac, and nine as 5093, according to PCR multiplex assays. Phage concentration was greater than 104 PFU/g for 25.3% of isolated phages. Seven phages showed an unusual wide host range, being able to infect a high number of the tested strains. Regarding thermal resistance, pac phages were the most sensitive, followed by cos phages, those classified as 5093 being the most resistant. Treatments at 85 °C for 5 min in TMG buffer were necessary to completely inactivate all phages. Results demonstrated that the use, without control, of these whey derivatives as additives in dairy fermentations could be a threat because of the potential phage infection of starter strains. In this sense, these phages constitute a pool of new isolates used to improve the phage resistance of starter cultures applied today in the fermentative industry.

Asunto(s)

RESUMEN

This article provides information on the characteristics of diverse phages of lactic acid bacteria and highlights the incidence of their presence in different dairy fermentations. As it is known, thermal treatments on raw milk and use of sanitizers in the disinfection of surfaces and equipment are strategies usually applied in dairy to prevent bacteriophage infections. In this sense, this review mainly focuses on the existing data about the resistance against thermal treatments and sanitizers usually used in the dairy industry worldwide, and the differences found among bacteriophages of diverse genera are remarked upon. Also, we provide information concerning the problems that have arisen as a consequence of the potential presence of bacteriophages in cheese whey powder and derivatives when they are added in fermented dairy product manufacturing. Finally, some important conclusions on each topic are marked and checkpoints to be considered are suggested.

Asunto(s)

RESUMEN

The ability of twelve strains belonging to three Leuconostoc species (Leuconostoc mesenteroides, Leuconostoc lactis and Leuconostoc pseudomesenteroides) to grow under diverse sub-lethal technological stress conditions (cold, acidic, alkaline and osmotic) was evaluated in MRS broth. Two strains, Leuconostoc lactis Ln N6 and Leuconostoc mesenteroides Ln MB7, were selected based on their growth under sub-lethal conditions, and volatile profiles in RSM (reconstituted skim milk) at optimal and under stress conditions were analyzed. Growth rates under sub-lethal conditions were strain- and not species-dependent. Volatilomes obtained from the two strains studied were rather diverse. Particularly, Ln N6 (Ln. lactis) produced more ethanol and acetic acid than Ln MB7 (Ln. mesenteroides) and higher amounts and diversity of the rest of volatile compounds as well, at all times of incubation. For the two strains studied, most of stress conditions applied diminished the amounts of ethanol and acetic acid produced and the diversity and levels of the rest of volatile compounds. These results were consequence of the different capacity of the strains to grow under each stress condition tested.

Asunto(s)

RESUMEN

The aims of this work were to design and build a photocatalytic reactor (UV-A/TiO2) to study the inactivation of phages contained in bioaerosols, which constitute the main dissemination via phages in industrial environments. The reactor is a close system with recirculation that consists of a stainless steel camera (cubic form, side of 60 cm) in which air containing the phage particles circulates and an acrylic compartment with six borosilicate plates covered with TiO2. The reactor is externally illuminated by 20 UV-A lamps. Both compartments are connected by a fan to facilitate the sample circulation. Samples are injected into the camera using two piston nebulizers working in series whereas several methodologies for sampling (impinger/syringe, sampling on photocatalytic plates, and impact of air on slide) were assayed. The reactor setup was carried out using phage B1 (Lactobacillus plantarum), and assays demonstrated a decrease of phage counts of 2.7 log orders after 1 h of photocatalytic treatment. Photonic efficiencies of inactivation were assessed by phage sampling on the photocatalytic plates or by impact of air on a glass slide at the photocatalytic reactor exit. Efficiencies of the same order of magnitude were observed using both sampling methods. This study demonstrated that the designed photocatalytic reactor is effective to inactivate phage B1 (Lb. plantarum) contained in bioaerosols.

Asunto(s)

RESUMEN

A systematic study about the intrinsic resistance of 29 strains (26 autochthonous and 3 commercial ones), belonging to Leuconostoc genus, against diverse stress factors (thermal, acidic, alkaline, osmotic and oxidative) commonly present at industrial or conservation processes were evaluated. Exhaustive result processing was made by applying one-way ANOVA, Student's test (t), multivariate analysis by Principal Component Analysis (PCA) and Matrix Hierarchical Cluster Analysis. In addition, heat adaptation on 4 strains carefully selected based on previous data analysis was assayed. The strains revealed wide diversity of resistance to stress factors and, in general, a clear relationship between resistance and Leuconostoc species was established. In this sense, the highest resistance was shown by Leuconostoc lactis followed by Leuconostoc mesenteroides strains, while Leuconostoc pseudomesenteroides and Leuconostoc citreum strains revealed the lowest resistance to the stress factors applied. Heat adaptation improved thermal cell survival and resulted in a cross-resistance against the acidic factor. However, all adapted cells showed diminished their oxidative resistance. According to our knowledge, this is the first study regarding response of Leuconostoc strains against technological stress factors and could establish the basis for the selection of "more robust" strains and propose the possibility of improving their performance during industrial processes.

Asunto(s)

RESUMEN

Latent period, burst time, and burst size, kinetic parameters of phage infection characteristic of a given phage/host system, have been measured for a wide variety of lactic acid bacteria. However, most studies to date were conducted in optimal growth conditions of host bacteria and did not consider variations due to changes in external factors. In this work, we determined the effect of temperature, pH, and starvation on kinetic parameters of phages infecting Lactobacillus paracasei, Lactobacillus plantarum, and Leuconostoc mesenteroides. For kinetics assessment, one-step growth curves were carried out in MRS broth at optimal conditions (control), lower temperature, pH 6.0 and 5.0 (MRS6 and MRS5, respectively), or in medium lacking carbon (MRSN) or nitrogen (MRSC) sources. Phage infection was progressively impaired as environmental conditions were modified from optimal. At lower temperature or pH, infection was delayed, as perceived by longer latent and burst times. Burst size, however, was lower, equal or higher than for controls, but this effect was highly dependent on the particular phage-host system studied. Phage infection was strongly inhibited in MRSC, but only mildly impaired in MRSN. Nevertheless, growth of all the bacterial strains tested was severely compromised by starvation, without significant differences between MRSC and MRSN, indicating that nitrogen compounds are specifically required for a successful phage infection, beyond their influence on bacterial growth.

Asunto(s)

RESUMEN

BACKGROUND: Bacteriophages constitute a great threat to the activity of lactic acid bacteria used in industrial processes. Several factors can influence the infection cycle of bacteriophages. That is the case of the physiological state of host cells, which could produce inhibition or delay of the phage infection process. In the present work, the influence of Lactobacillus plantarum host cell starvation on phage B1 adsorption and propagation was investigated. RESULT: First, cell growth kinetics of L. plantarum ATCC 8014 were determined in MRS, limiting carbon (S-N), limiting nitrogen (S-C) and limiting carbon/nitrogen (S) broth. L. plantarum ATCC 8014 strain showed reduced growth rate under starvation conditions in comparison to the one obtained in MRS broth. Adsorption efficiencies of > 99 % were observed on the starved L. plantarum ATCC 8014 cells. Finally, the influence of cell starvation conditions in phage propagation was investigated through one-step growth curves. In this regard, production of phage progeny was studied when phage infection began before or after cell starvation. When bacterial cells were starved after phage infection, phage B1 was able to propagate in L. plantarum ATCC 8014 strain in a medium devoid of carbon source (S-N) but not when nitrogen (S-C broth) or nitrogen/carbon (S broth) sources were removed. However, addition of nitrogen and carbon/nitrogen compounds to starved infected cells caused the restoration of phage production. When bacterial cells were starved before phage infection, phage B1 propagated in either nitrogen or nitrogen/carbon starved cells only when the favorable conditions of culture (MRS) were used as a propagation medium. Regarding carbon starved cells, phage propagation in either MRS or S-N broth was evidenced. CONCLUSIONS: These results demonstrated that phage B1 could propagate in host cells even in unfavorable culture conditions, becoming a hazardous source of phages that could disseminate to industrial environments.

Asunto(s)

RESUMEN

The survival of three Lactobacillus plantarum strains (Lp 790, Lp 813 and Lp 998) with functional properties was studied taking into account their resistance to thermal, osmotic and oxidative stress factors. Stress treatments applied were: 52 °C-15 min (Phosphate Buffer pH 7, thermal shock), H2O2 0.1% (p/v) - 30 min (oxidative shock) and NaCl aqueous solution at 17, 25 and 30% (p/v) (room temperature - 1 h, osmotic shock). The osmotic stress was also evaluated on cell growth in MRS broth added of 2, 4, 6, 8 and 10% (p/v) of NaCl, during 20 h at 30 °C. The cell thermal adaptation was performed in MRS broth, selecting 45 °C for 30 min as final conditions for all strains. Two strains (Lp 813 and Lp 998) showed, in general, similar behaviour against the three stress factors, being clearly more resistant than Lp 790. An evident difference in growth kinetics in presence of NaCl was observed between Lp 998 and Lp 813, Lp998 showing a higher optical density (OD570nm) than Lp 813 at the end of the assay. Selected thermal adaptation improved by 2 log orders the thermal resistance of both strains, but cell growth in presence of NaCl was enhanced only in Lp 813. Oxidative resistance was not affected with this thermal pre-treatment. These results demonstrate the relevance of cell technological resistance when selecting presumptive "probiotic" cultures, since different stress factors might considerably affect viability or/and performance of the strains. The incidence of stress conditions on functional properties of the strains used in this work are currently under research in our group.

Asunto(s)

RESUMEN

Phages infecting Leuconostoc mesenteroides strains can be overlooked during milk fermentation because they do not slowdown the acidification process. However, they can negatively impact the flavor profile of the final product. Yet, the information about these phages is still scarce. In this work, we investigated diverse factors influencing the adsorption of seven virulent Ln. mesenteroides phages, isolated from blue cheese manufacture in Argentina, to their host cells. The addition of calcium ions was generally necessary to observe complete cell lysis and plaque formation for four of the seven phages, but adsorption was very high even in the absence of this cation for all phages. The temperature barely influenced the adsorption process as it was high within the temperature range tested (0 to 50 °C). Moreover, the kinetics of adsorption were similar on viable and non-viable cells, revealing that phage adsorption does not depend on physiological state of the bacterial cells. The adsorption rates were also high at pH values from 4 to 9 for all Ln. mesenteroides phages. We also analyzed the complete genome sequences of two of these phages. Complete nucleotide analysis of phages Ln-8 and Ln-9 showed dsDNA genomes with sizes of 28.5 and 28.9 kb, and the presence of 45 and 48 open reading frames (ORFs), respectively. These genomes were highly similar to those of previously characterized Φ1-A4 (USA, sauerkraut, fermentation) and ΦLN25 (England, whey), both virulent Ln. mesenteroides phages. A detailed understanding of these phages will lead to better control strategies.

Asunto(s)

RESUMEN

BACKGROUND/AIMS: Adsorption and kinetic parameters, latent period, burst size and burst time, are characteristics of phage/host systems and can be affected by several environmental factors. As only few studies have focused on temperate dairy phages, we characterized these parameters on temperate Lactobacillus paracasei phages Φ iLp84 and Φ iLp1308, infective for probiotic strains. METHODS: Phages were characterized by transmission electron microscopy and genomic DNA restriction. Adsorption under different environmental conditions, phage kinetics and efficiency of plating (EOP) were determined using the double-layer titration method. RESULTS: Phages Φ iLp84 and Φ iLp1308 belong to the Siphoviridae family and have genome sizes of 38 and 34 kbp, respectively. Adsorption was affected by calcium concentration, pH, temperature and host viability, and reached a limit at very high multiplicity of infection. Latency, burst time and burst size were of 85 min, 131 min and 46 for Φ iLp84, and 51 min, 92 min and 28 for Φ iLp1308, respectively, at 37°C. A clear influence of temperature on phage kinetics was observed. Regarding EOP, Φ iLp84 produced plaques on only 1 out of 8 strains tested. CONCLUSION: Noticeable differences in adsorption, kinetics and EOP were found for two morphologically identical temperate L. paracasei phages of similar origin.

Asunto(s)

RESUMEN

Nine Leuconostoc mesenteroides phages were isolated during blue cheese manufacture yielding faulty products with reduced eye formation. Their morphologies, restriction profiles, host ranges and long-term survival rates (25°C, 8°C, -20°C and -80°C) were analysed. Based on restriction analysis, six of them were further examined regarding resistance to physical (heat and high pressure homogenization, HPH) and chemical treatments (ethanol, sodium hypochlorite, peracetic acid, biocides A, C, E and F). According to their morphology, L. mesenteroides phages studied in the present work belonged to the Caudovirales order and Siphoviridae family. Six distinct restriction patterns were obtained with EcoRV, HindIII, ClaI and XhoI enzymes, revealing interesting phage diversity in the dairy environment. No significant reductions in phage counts were observed after ten months of storage at -20°C and -80°C, while slightly and moderate decrease in phage numbers were noticed at 8°C and 25°C, respectively. The phages subjected to heat treatments generally showed high resistance at 63°C and moderate resistance at 72°C. However, 80°C for 30 min and 90°C for 2 min led to complete inactivation of viral particles. In general, the best ethanol concentration tested was 75%, as complete inactivation for most Leuconostoc phages within 30 min of incubation was achieved. Peracetic acid, and biocides A, C, E and F were highly effective when used at the same or at a moderately lower concentration as recommended by the producer. Usually, moderate or high concentrations (600-1,600 ppm) of sodium hypochlorite were necessary to completely inactivate phage particles. Leuconostoc phages were partially inactivated by HPH treatments as remaining viral particles were found even after 8 passes at 100 MPa. This is the first report of L. mesenteroides phages isolated from an Argentinean dairy cheese plant. The results of this work could be useful for establishing the most effective physical and chemical treatments for inactivating phages in industrial plants and laboratory environments.

Asunto(s)

RESUMEN

Cell-free supernatant from Leuconostoc citreum MB1 revealed specific antilisterial activity. Preliminary studies demonstrated the proteinaceous, heat-stable, bacteriocin-like trait of the antimicrobial components present in the supernatant. Determination of the genes encoding bacteriocins by PCR and DNA sequencing led to amplification products highly homologous with leucocin A (found in diverse Leuconostoc species) and UviB (found in Leuc. citreum KM20) sequences. Additionally, antimicrobial activity of cell-free supernatant from Leuc. citreum MB1 was revealed by an inhibition halo of the SDS-PAGE gel subjected to a direct detection using Listeria monocytogenes as indicator strain. Different assays were carried out to assess the capacity of Leuc.citreum MB1 to control List. monocytogenes growth: (i) inactivation kinetics of the pathogen by antilisterial compounds present in concentrated cell-free supernatant from Leuc. citreum MB1, (ii) evaluation of optimal Leuc. citreum MB1 initial concentration to obtain maximum List. monocytogenes ATCC 15313 inhibition, and (iii) biocontrol of List. monocytogenes ATCC 15313 with Leuc. citreum MB1 during growth in milk at refrigeration temperature. According to our results, it is unquestionable that at least one bacteriocin is active in Leuc. citreum MB1, since important antilisterial activity was verified either in its cell-free supernatant or in co-culture experiments. Co-culture tests showed that ∼107 CFU/ml Leuc. citreum MB1 was the optimal initial concentration to obtain maximum pathogen inhibition. Moreover, Leuc. citreum MB1 was able to delay List. monocytogenes growth at refrigerated temperature.

Asunto(s)

RESUMEN

Ten bacteriophages were isolated from faeces and their lytic effects assayed on 103 pathogenic and non-pathogenic Enterobacteriaceae. Two phages (DT1 and DT6) were selected based on their host ranges, and their lytic effects on pathogenic E. coli strains inoculated on pieces of beef were determined. We evaluated the reductions of viable cells of Escherichia coli O157:H7 and non-O157 Shiga toxigenic E. coli strains on meat after exposure to DT6 at 5 and 24°C for 3, 6, and 24 h and the effect of both phages against an enteropathogenic E. coli strain. Significant viable cell reductions, compared to controls without phages, at both temperatures were observed, with the greatest decrease taking place within the first hours of the assays. Reductions were also influenced by phage concentration, being the highest concentrations, 1.7 × 10(10) plaque forming units per milliliter (PFU/mL) for DT1 and 1.4 × 10(10) PFU/mL for DT6, the most effective. When enteropathogenic E. coli and Shiga toxigenic E. coli (O157:H7) strains were tested, we obtained viable cell reductions of 0.67 log (p = 0.01) and 0.77 log (p = 0.01) after 3 h incubation and 0.80 log (p = 0.01) and 1.15 log (p = 0.001) after 6 h. In contrast, all nonpathogenic E. coli strains as well as other enterobacteria tested were resistant. In addition, phage cocktail was evaluated on two strains and further reductions were observed. However, E. coli bacteriophage insensitive mutants (BIMs) emerged in meat assays. BIMs isolated from meat along with those isolated by using the secondary culture method were tested to evaluate resistance phenotype stability and reversion. They presented low emergence frequencies (6.5 × 10(-7)-1.8 × 10(-6)) and variable stability and reversion. Results indicate that isolated phages were stable on storage, negative for all the virulence factors assayed, presented lytic activity for different E. coli virotypes and could be useful in reducing Shiga toxigenic E. coli and enteropathogenic E. coli viable cells in meat products.

Asunto(s)

RESUMEN

We characterized two Lactobacillus plantarum virulent siphophages, ATCC 8014-B1 (B1) and ATCC 8014-B2 (B2), previously isolated from corn silage and anaerobic sewage sludge, respectively. Phage B2 infected two of the eight L. plantarum strains tested, while phage B1 infected three. Phage adsorption was highly variable depending on the strain used. Phage defense systems were found in at least two L. plantarum strains, LMG9211 and WCSF1. The linear double-stranded DNA genome of the pac-type phage B1 had 38,002 bp, a G+C content of 47.6%, and 60 open reading frames (ORFs). Surprisingly, the phage B1 genome has 97% identity with that of Pediococcus damnosus phage clP1 and 77% identity with that of L. plantarum phage JL-1; these phages were isolated from sewage and cucumber fermentation, respectively. The double-stranded DNA (dsDNA) genome of the cos-type phage B2 had 80,618 bp, a G+C content of 36.9%, and 127 ORFs with similarities to those of Bacillus and Lactobacillus strains as well as phages. Some phage B2 genes were similar to ORFs from L. plantarum phage LP65 of the Myoviridae family. Additionally, 6 tRNAs were found in the phage B2 genome. Protein analysis revealed 13 (phage B1) and 9 (phage B2) structural proteins. To our knowledge, this is the first report describing such high identity between phage genomes infecting different genera of lactic acid bacteria.

Asunto(s)

RESUMEN

Este trabalho teve como objetivos isolar bacteriófagos de amostras de leite, soro e queijo de Coalho e avaliar a resistência de cepas de Lactobacillus paracasei, pertencentes à Coleção de Micro-organismos de Interesse para a Agroindústria Tropical da Embrapa Agroindústria Tropical, aos fagos isolados. Posteriormente, a resistência destas cepas a fagos específicos para L. paracasei, da Coleção do Instituto de Lactología Industrial - INLAIN (Santa Fe, Argentina), também foi avaliada. As amostras para isolamento dos fagos foram obtidas em quatro unidades de processamento de queijo de Coalho, sendo duas artesanais e duas industriais, localizadas no Estado do Ceará. Para o isolamento dos bacteriófagos, foi empregado o teste de lise celular (spot), enquanto que a resistência das culturas aos fagos foi avaliada pelos testes de capacidade de produção de ácido e avaliação da turbidez. As cepas avaliadas foram resistentes aos bacteriófagos provenientes das unidades de processamento de queijo de Coalho e aos bacteriófagos da Coleção do INLAIN. Os resultados obtidos indicaram que as culturas láticas testadas, resistentes aos bacteriófagos, podem ser utilizadas na composição de fermento lático destinado à elaboração de queijo de Coalho, a partir de leite pasteurizado.

The objectives of this research were to isolate bacteriophages from milk samples, whey and Coalho cheese and to evaluate the resistance of strains of Lactobacillus paracasei from the Collection of Microorganisms of Interest for the Tropical Agroindustry, belonging to Embrapa Tropical Agroindustry, to isolate phages. The strains resistance to specific L. paracasei phages from the collection of the Instituto de Lactología Industrial - INLAIN (Santa Fe, Argentina) was also evaluated. Samples for phage isolation were from four Coalho cheese processing units, two artisanal and two industrial, localized in the state of Ceará. Spot test was employed for bacteriophages isolation, while the culture phage resistance was evaluated by the acid production and turbidity tests. The strains were resistant both to phages isolated from Coalho cheese processing units and phages from collection of INLAIN. The results showed that lactic cultures evaluated here were resistant to bacteriophages and they can be used in the composition of lactic cultures specifically for Coalho cheese manufacture from pasteurized milk.

RESUMEN

This review highlights the main strategies available to control phage infection during large-scale milk fermentation by lactic acid bacteria. The topics that are emphasized include the factors influencing bacterial activities, the sources of phage contamination, the methods available to detect and quantify phages, as well as practical solutions to limit phage dispersion through an adapted factory design, the control of air flow, the use of adequate sanitizers, the restricted used of recycled products, and the selection and growth of bacterial cultures.

RESUMEN

The objectives of this research were to isolate bacteriophages from milk samples, whey and Coalho cheese and to evaluate the resistance of strains of Lactobacillus paracasei from the Collection of Microorganisms of Interest for the Tropical Agroindustry, belonging to Embrapa Tropical Agroindustry, to isolate phages. The strains resistance to specific L. paracasei phages from the collection of the Instituto de Lactología Industrial - INLAIN (Santa Fe, Argentina) was also evaluated. Samples for phage isolation were from four Coalho cheese processing units, two artisanal and two industrial, localized in the state of Ceará. Spot test was employed for bacteriophages isolation, while the culture phage resistance was evaluated by the acid production and turbidity tests. The strains were resistant both to phages isolated from Coalho cheese processing units and phages from collection of INLAIN. The results showed that lactic cultures evaluated here were resistant to bacteriophages and they can be used in the composition of lactic cultures specifically for Coalho cheese manufacture from pasteurized milk.

Este trabalho teve como objetivos isolar bacteriófagos de amostras de leite, soro e queijo de Coalho e avaliar a resistência de cepas de Lactobacillus paracasei, pertencentes à Coleção de Micro-organismos de Interesse para a Agroindústria Tropical da Embrapa Agroindústria Tropical, aos fagos isolados. Posteriormente, a resistência destas cepas a fagos específicos para L. paracasei, da Coleção do Instituto de Lactología Industrial - INLAIN (Santa Fe, Argentina), também foi avaliada. As amostras para isolamento dos fagos foram obtidas em quatro unidades de processamento de queijo de Coalho, sendo duas artesanais e duas industriais, localizadas no Estado do Ceará. Para o isolamento dos bacteriófagos, foi empregado o teste de lise celular (spot), enquanto que a resistência das culturas aos fagos foi avaliada pelos testes de capacidade de produção de ácido e avaliação da turbidez. As cepas avaliadas foram resistentes aos bacteriófagos provenientes das unidades de processamento de queijo de Coalho e aos bacteriófagos da Coleção do INLAIN. Os resultados obtidos indicaram que as culturas láticas testadas, resistentes aos bacteriófagos, podem ser utilizadas na composição de fermento lático destinado à elaboração de queijo de Coalho, a partir de leite pasteurizado.

RESUMEN

The objectives of this research were to isolate bacteriophages from milk samples, whey and Coalho cheese and to evaluate the resistance of strains of Lactobacillus paracasei from the Collection of Microorganisms of Interest for the Tropical Agroindustry, belonging to Embrapa Tropical Agroindustry, to isolate phages. The strains resistance to specific L. paracasei phages from the collection of the Instituto de Lactología Industrial - INLAIN (Santa Fe, Argentina) was also evaluated. Samples for phage isolation were from four Coalho cheese processing units, two artisanal and two industrial, localized in the state of Ceará. Spot test was employed for bacteriophages isolation, while the culture phage resistance was evaluated by the acid production and turbidity tests. The strains were resistant both to phages isolated from Coalho cheese processing units and phages from collection of INLAIN. The results showed that lactic cultures evaluated here were resistant to bacteriophages and they can be used in the composition of lactic cultures specifically for Coalho cheese manufacture from pasteurized milk.

Este trabalho teve como objetivos isolar bacteriófagos de amostras de leite, soro e queijo de Coalho e avaliar a resistência de cepas de Lactobacillus paracasei, pertencentes à Coleção de Micro-organismos de Interesse para a Agroindústria Tropical da Embrapa Agroindústria Tropical, aos fagos isolados. Posteriormente, a resistência destas cepas a fagos específicos para L. paracasei, da Coleção do Instituto de Lactología Industrial - INLAIN (Santa Fe, Argentina), também foi avaliada. As amostras para isolamento dos fagos foram obtidas em quatro unidades de processamento de queijo de Coalho, sendo duas artesanais e duas industriais, localizadas no Estado do Ceará. Para o isolamento dos bacteriófagos, foi empregado o teste de lise celular (spot), enquanto que a resistência das culturas aos fagos foi avaliada pelos testes de capacidade de produção de ácido e avaliação da turbidez. As cepas avaliadas foram resistentes aos bacteriófagos provenientes das unidades de processamento de queijo de Coalho e aos bacteriófagos da Coleção do INLAIN. Os resultados obtidos indicaram que as culturas láticas testadas, resistentes aos bacteriófagos, podem ser utilizadas na composição de fermento lático destinado à elaboração de queijo de Coalho, a partir de leite pasteurizado.

RESUMEN

Bacteriophages can cause great economic losses due to fermentation failure in dairy plants. Hence, physical and chemical treatments of raw material and/or equipment are mandatory to maintain phage levels as low as possible. Regarding thermal treatments used to kill pathogenic bacteria or achieve longer shelf-life of dairy products, neither low temperature long time nor high temperature short time pasteurization were able to inactivate most lactic acid bacteria (LAB) phages. Even though most phages did not survive 90°C for 2 min, there were some that resisted 90°C for more than 15 min (conditions suggested by the International Dairy Federation, for complete phage destruction). Among biocides tested, ethanol showed variable effectiveness in phage inactivation, since only phages infecting dairy cocci and Lactobacillus helveticus were reasonably inactivated by this alcohol, whereas isopropanol was in all cases highly ineffective. In turn, peracetic acid has consistently proved to be very fast and efficient to inactivate dairy phages, whereas efficiency of sodium hypochlorite was variable, even among different phages infecting the same LAB species. Both alkaline chloride foam and ethoxylated non-ylphenol with phosphoric acid were remarkably efficient, trait probably related to their highly alkaline or acidic pH values in solution, respectively. Photocatalysis using UV light and TiO(2) has been recently reported as a feasible option to industrially inactivate phages infecting diverse LAB species. Processes involving high pressure were barely used for phage inactivation, but until now most studied phages revealed high resistance to these treatments. To conclude, and given the great phage diversity found on dairies, it is always advisable to combine different anti-phage treatments (biocides, heat, high pressure, photocatalysis), rather than using them separately at extreme conditions.