RESUMEN
BACKGROUND: On-site cellulase production using locally available lignocellulosic biomass (LCB) is essential for cost-effective production of 2nd-generation biofuels. Cellulolytic enzymes (cellulases and hemicellulases) must be produced in fed-batch mode in order to obtain high productivity and yield. To date, the impact of the sugar composition of LCB hydrolysates on cellulolytic enzyme secretion has not been thoroughly investigated in industrial conditions. RESULTS: The effect of sugar mixtures (glucose, xylose, inducer) on the secretion of cellulolytic enzymes by a glucose-derepressed and cellulase-hyperproducing mutant strain of Trichoderma reesei (strain CL847) was studied using a small-scale protocol representative of the industrial conditions. Since production of cellulolytic enzymes is inducible by either lactose or cellobiose, two parallel mixture designs were performed separately. No significant difference between inducers was observed on cellulase secretion performance, probably because a common induction mechanism occurred under carbon flux limitation. The characteristics of the enzymatic cocktails did not correlate with productivity, but instead were rather dependent on the substrate composition. Increasing xylose content in the feed had the strongest impact. It decreased by 2-fold cellulase, endoglucanase, and cellobiohydrolase activities and by 4-fold ß-glucosidase activity. In contrast, xylanase activity was increased 6-fold. Accordingly, simultaneous high ß-glucosidase and xylanase activities in the enzymatic cocktails seemed to be incompatible. The variations in enzymatic activity were modelled and validated with four fed-batch cultures performed in bioreactors. The overall enzyme production was maintained at its highest level when substituting up to 75% of the inducer with non-inducing sugars. CONCLUSIONS: The sugar substrate composition strongly influenced the composition of the cellulolytic cocktail secreted by T. reesei in fed-batch mode. Modelling can be used to predict cellulolytic activity based on the sugar composition of the culture-feeding solution, or to fine tune the substrate composition in order to produce a desired enzymatic cocktail.
RESUMEN
Isopropanol represents a widely-used commercial alcohol which is currently produced from petroleum. In nature, isopropanol is excreted by some strains of Clostridium beijerinckii, simultaneously with butanol and ethanol during the isopropanol butanol ethanol (IBE) fermentation. In order to increase isopropanol production, the gene encoding the secondary-alcohol dehydrogenase enzyme from C. beijerinckii NRRL B593 (adh) which catalyzes the reduction of acetone to isopropanol, was cloned into the acetone, butanol and ethanol (ABE)-producing strain C. acetobutylicum ATCC 824. The transformants showed high capacity for conversion of acetone into isopropanol (> 95%). To increase isopropanol production levels in ATCC 824, polycistronic transcription units containing, in addition to the adh gene, homologous genes of the acetoacetate decarboxylase (adc), and/or the acetoacetyl-CoA:acetate/butyrate:CoA transferase subunits A and B (ctfA and ctfB) were constructed and introduced into the wild-type strain. Combined overexpression of the ctfA and ctfB genes resulted in enhanced solvent production. In non-pH-controlled batch cultures, the total solvents excreted by the transformant overexpressing the adh, ctfA, ctfB and adc genes were 24.4 g/L IBE (including 8.8 g/L isopropanol), while the control strain harbouring an empty plasmid produced only 20.2 g/L ABE (including 7.6 g/L acetone). The overexpression of the adc gene had limited effect on IBE production. Interestingly, all transformants with the adh gene converted acetoin (a minor fermentation product) into 2,3-butanediol, highlighting the wide metabolic versatility of solvent-producing Clostridia.
RESUMEN
BACKGROUND: During bioprocess development, secondary screening is a key step at the boundary between laboratory and industrial conditions. To ensure an effective high-throughput screening, miniaturized laboratory conditions must mimic industrial conditions, especially for oxygen transfer, feeding capacity and pH stabilization. RESULTS: A feeding strategy has been applied to develop a simple screening procedure, in which a stoichiometric study is combined with a standard miniaturization procedure. Actually, the knowledge of all nutriments and base or acid requirements leads to a great simplification of pH stabilization issue of miniaturized fed-batch cultures. Applied to cellulase production by Trichoderma reesei, this strategy resulted in a stoichiometric mixed feed of carbon and nitrogen sources. While keeping the pH between shake flask and stirred bioreactor comparable, the developed shake flask protocol reproduced the strain behaviour under stirred bioreactor conditions. Compared to a an already existing miniaturized shake flasks protocol, the cellulase concentration was increased 5-fold, reaching about 10 g L-1. Applied to the secondary screening of several clones, the newly developed protocol succeeded in selecting a clone with a high industrial potential. CONCLUSIONS: The understanding of a bioprocess stoichiometry contributed to define a simpler and more effective miniaturization. The suggested strategy can potentially be applied to other fed-batch processes, for the screening of either strain collections or experimental conditions.
Asunto(s)
Celulasa/metabolismo , Proteínas Fúngicas/metabolismo , Microbiología Industrial/métodos , Miniaturización/métodos , Trichoderma/enzimología , Técnicas de Cultivo Celular por Lotes , Celulasa/genética , Fermentación , Proteínas Fúngicas/genética , Trichoderma/genéticaRESUMEN
BACKGROUND: The enzymatic hydrolysis of cellulose is still considered as one of the main limiting steps of the biological production of biofuels from lignocellulosic biomass. It is a complex multistep process, and various kinetic models have been proposed. The cellulase enzymatic cocktail secreted by Trichoderma reesei has been intensively investigated. beta-glucosidases are one of a number of cellulolytic enzymes, and catalyze the last step releasing glucose from the inhibitory cellobiose. beta-glucosidase (BGL1) is very poorly secreted by Trichoderma reesei strains, and complete hydrolysis of cellulose often requires supplementation with a commercial beta-glucosidase preparation such as that from Aspergillus niger (Novozymes SP188). Surprisingly, kinetic modeling of beta-glucosidases lacks reliable data, and the possible differences between native T. reesei and supplemented beta-glucosidases are not taken into consideration, possibly because of the difficulty of purifying BGL1. RESULTS: A comparative kinetic analysis of beta-glucosidase from Aspergillus niger and BGL1 from Trichoderma reesei, purified using a new and efficient fast protein liquid chromatography protocol, was performed. This purification is characterized by two major steps, including the adsorption of the major cellulases onto crystalline cellulose, and a final purification factor of 53. Quantitative analysis of the resulting beta-glucosidase fraction from T. reesei showed it to be 95% pure. Kinetic parameters were determined using cellobiose and a chromogenic artificial substrate. A new method allowing easy and rapid determination of the kinetic parameters was also developed. beta-Glucosidase SP188 (Km = 0.57 mM; Kp = 2.70 mM) has a lower specific activity than BGL1 (Km = 0.38 mM; Kp = 3.25 mM) and is also more sensitive to glucose inhibition. A Michaelis-Menten model integrating competitive inhibition by the product (glucose) has been validated and is able to predict the beta-glucosidase activity of both enzymes. CONCLUSIONS: This article provides a useful comparison between the activity of beta-glucosidases from two different fungi, and shows the importance of fully characterizing both enzymes. A Michaelis-Menten model was developed, including glucose inhibition and kinetic parameters, which were accurately determined and compared. This model can be further integrated into a cellulose hydrolysis model dissociating beta-glucosidase activity from that of other cellulases. It can also help to define the optimal enzymatic cocktails for new beta-glucosidase activities.
RESUMEN
Trichoderma reesei (teleomorph Hypocrea jecorina) is the main industrial source of cellulases and hemicellulases harnessed for the hydrolysis of biomass to simple sugars, which can then be converted to biofuels such as ethanol and other chemicals. The highly productive strains in use today were generated by classical mutagenesis. To learn how cellulase production was improved by these techniques, we performed massively parallel sequencing to identify mutations in the genomes of two hyperproducing strains (NG14, and its direct improved descendant, RUT C30). We detected a surprisingly high number of mutagenic events: 223 single nucleotides variants, 15 small deletions or insertions, and 18 larger deletions, leading to the loss of more than 100 kb of genomic DNA. From these events, we report previously undocumented non-synonymous mutations in 43 genes that are mainly involved in nuclear transport, mRNA stability, transcription, secretion/vacuolar targeting, and metabolism. This homogeneity of functional categories suggests that multiple changes are necessary to improve cellulase production and not simply a few clear-cut mutagenic events. Phenotype microarrays show that some of these mutations result in strong changes in the carbon assimilation pattern of the two mutants with respect to the wild-type strain QM6a. Our analysis provides genome-wide insights into the changes induced by classical mutagenesis in a filamentous fungus and suggests areas for the generation of enhanced T. reesei strains for industrial applications such as biofuel production.
Asunto(s)
Celulasa/genética , Proteínas Fúngicas/genética , Genoma Fúngico/genética , Análisis de Secuencia de ADN/métodos , Trichoderma/genética , Composición de Base , Celulasa/metabolismo , ADN de Hongos/química , ADN de Hongos/genética , Proteínas Fúngicas/metabolismo , Genes Fúngicos , Mutación , Polimorfismo de Nucleótido Simple , Especificidad de la Especie , Trichoderma/clasificación , Trichoderma/enzimologíaRESUMEN
The use of lignocellulosic biomass for the production of biofuels will be unavoidable if liquid fossil fuels are to be replaced by renewable and sustainable alternatives. Ethanol accounts for the majority of biofuel use worldwide, and the prospect of its biological production from abundant lignocellulosic feedstocks is attractive. The recalcitrance of these raw materials still renders proposed processes complex and costly, but there are grounds for optimism. The application of new, engineered enzyme systems for cellulose hydrolysis, the construction of inhibitor-tolerant pentose-fermenting industrial yeast strains, combined with optimized process integration promise significant improvements. The opportunity to test these advances in pilot plants paves the way for large-scale units. This review summarizes recent progress in this field, including the validation at pilot scale, and the economic and environmental impacts of this production pathway.
Asunto(s)
Biotecnología/métodos , Etanol/metabolismo , Lignina/metabolismo , Biotecnología/economía , AmbienteRESUMEN
BACKGROUND: Due to its capacity to produce large amounts of cellulases, Trichoderma reesei is increasingly been researched in various fields of white biotechnology, especially in biofuel production from lignocellulosic biomass. The commercial enzyme mixtures produced at industrial scales are not well characterized, and their proteinaceous components are poorly identified and quantified. The development of proteomic methods has made it possible to comprehensively overview the enzymes involved in lignocellulosic biomass degradation which are secreted under various environmental conditions. RESULTS: The protein composition of the secretome produced by industrial T. reesei (strain CL847) grown on a medium promoting the production of both cellulases and hemicellulases was explored using two-dimensional electrophoresis and MALDI-TOF or LC-MS/MS protein identification. A total of 22 protein species were identified. As expected, most of them are potentially involved in biomass degradation. The 2D map obtained was then used to compare the secretomes produced by CL847 and another efficient cellulolytic T. reesei strain, Rut-C30, the reference cellulase-overproducing strain using lactose as carbon source and inducer of cellulases. CONCLUSION: This study provides the most complete mapping of the proteins secreted by T. reesei to date. We report on the first use of proteomics to compare secretome composition between two cellulase-overproducing strains Rut-C30 and CL847 grown under similar conditions. Comparison of protein patterns in both strains highlighted many unexpected differences between cellulase cocktails. The results demonstrate that 2D electrophoresis is a promising tool for studying cellulase production profiles, whether for industrial characterization of an entire secretome or for a more fundamental study on cellulase expression at genome-wide scale.
RESUMEN
Mycobacterium austroafricanum IFP 2012 is able to slowly grow on methyl tert-butyl ether (MTBE), a fuel oxygenate widely used as a gasoline additive. The potential of M. austroafricanum IFP 2012 for aerobic MTBE degradation was investigated in the presence of a secondary carbon source, isopropanol. The strain was then tested for MTBE biodegradation at the laboratory-scale in a fixed-bed reactor using perlite as the matrix, and isopropanol was injected once a week to maintain M. austroafricanum IFP 2012 biomass inside the perlite bed. The biofilter was operated for 85 days at an influent flow rate of 20 ml/h by varying the MTBE concentration from 10 to 20 mg/l. The hydraulic retention time was fixed at 5 days. The removal of MTBE depended on the inlet MTBE concentration and a MTBE removal efficiency higher than 99% was obtained for MTBE concentrations up to 15 mg/l. A set of 16S rRNA gene primers specific for M. austroafricanum species was used to analyze the DNA extracted from the biofilter effluent in order to detect the presence of M. austroafricanum IFP 2012 and to estimate the effect of periodic injections of isopropanol on the release of the strain from the perlite bed. The results demonstrated that the injection of isopropanol served to maintain an active MTBE degrading biomass in the biofilter and that this system could be used to effectively treat MTBE contaminated groundwater.
Asunto(s)
Reactores Biológicos , Biotecnología , Éteres Metílicos/metabolismo , Mycobacterium/metabolismo , 2-Propanol/metabolismo , Biomasa , Gasolina , Mycobacterium/clasificación , Contaminantes Químicos del Agua/metabolismoRESUMEN
Mycobacterium austroafricanum IFP 2012, which grows on methyl tert-butyl ether (MTBE) and on tert-butyl alcohol (TBA), the main intermediate of MTBE degradation, also grows on a broad range of n-alkanes (C2 to C16). A single alkB gene copy, encoding a non-heme alkane monooxygenase, was partially amplified from the genome of this bacterium. Its expression was induced after growth on n-propane, n-hexane, n-hexadecane and on TBA but not after growth on LB. The capacity of other fast-growing mycobacteria to grow on n-alkanes (C1 to C16) and to degrade TBA after growth on n-alkanes was compared to that of M. austroafricanum IFP 2012. We studied M. austroafricanum IFP 2012 and IFP 2015 able to grow on MTBE, M. austroafricanum IFP 2173 able to grow on isooctane, Mycobacterium sp. IFP 2009 able to grow on ethyl tert-butyl ether (ETBE), M. vaccae JOB5 (M. austroaafricanum ATCC 29678) able to degrade MTBE and TBA and M. smegmatis mc2 155 with no known degradation capacity towards fuel oxygenates. The M. austroafricanum strains grew on a broad range of n-alkanes and three were able to degrade TBA after growth on propane, hexane and hexadecane. An alkB gene was partially amplified from the genome of all mycobacteria and a sequence comparison demonstrated a close relationship among the M. austroafricanum strains. This is the first report suggesting the involvement of an alkane hydroxylase in TBA oxidation, a key step during MTBE metabolism.
Asunto(s)
Alcanos/metabolismo , Oxigenasas de Función Mixta/metabolismo , Mycobacterium/metabolismo , Alcohol terc-Butílico/metabolismo , Secuencia de Aminoácidos , Proteínas Bacterianas/genética , Proteínas Bacterianas/metabolismo , Biodegradación Ambiental , ADN Bacteriano/genética , ADN Ribosómico/genética , Expresión Génica , Genoma Bacteriano , Oxigenasas de Función Mixta/genética , Datos de Secuencia Molecular , Mycobacterium/clasificación , Mycobacterium/genética , Mycobacterium/crecimiento & desarrollo , Oxidación-Reducción , Filogenia , ARN Ribosómico 16S/genética , Alineación de SecuenciaRESUMEN
The main goals of this work were to produce the fusion protein of the Trichoderma reesei swollenin I (SWOI) and Aspergillus niger feruloyl esterase A (FAEA) and to study the effect of the physical association of the fusion partners on the efficiency of the enzyme. The fusion protein was produced up to 25 mg l(-1) in the T. reesei strains Rut-C30 and CL847. In parallel, FAEA alone was produced for use as a control protein in application tests. Recombinant FAEA and SWOI-FAEA were purified to homogeneity and characterized. The biochemical and kinetic characteristics of the two recombinant proteins were found to be similar to those of native FAEA, except for the temperature stability and specific activity of the SWOI-FAEA. Finally, the SWOI-FAEA protein was tested for release of ferulic acid from wheat bran. A period of 24 h of enzymatic hydrolysis with the SWOI-FAEA improved the efficiency of ferulic acid release by 50% compared with the results obtained using the free FAEA and SWOI. Ferulic acid is used as an antioxidant and flavor precursor in the food and pharmaceutical industries. This is the first report of a potential application of the SWOI protein fused with an enzyme of industrial interest.
Asunto(s)
Aspergillus niger/enzimología , Hidrolasas de Éster Carboxílico/metabolismo , Ácidos Cumáricos/metabolismo , Proteínas Fúngicas/metabolismo , Trichoderma/enzimología , Aspergillus niger/genética , Hidrolasas de Éster Carboxílico/genética , Fibras de la Dieta/metabolismo , Estabilidad de Enzimas , Proteínas Fúngicas/genética , Concentración de Iones de Hidrógeno , Cinética , Proteínas Recombinantes de Fusión/genética , Proteínas Recombinantes de Fusión/aislamiento & purificación , Proteínas Recombinantes de Fusión/metabolismo , Temperatura , Factores de Tiempo , Trichoderma/genéticaRESUMEN
Methyl tert-butyl ether (MTBE) is a persistent pollutant of surface and groundwater, and the reasons for its low biodegradability are poorly documented. Using one of the rare bacterial strains able to grow in the presence of MTBE, Mycobacterium austroafricanum IFP 2012, the protein profiles of crude extracts after growth in the presence of MTBE and glucose were compared by SDS-PAGE. Ten proteins with molecular masses of 67, 64, 63, 55, 50, 27, 24, 17, 14 and 11 kDa were induced after growth in the presence of MTBE. Partial amino acid sequences of N-terminal and internal peptide fragments of the 64 kDa protein were used to design degenerate oligonucleotide primers to amplify total DNA by PCR, yielding a DNA fragment that was used as a probe for cloning. A two-step cloning procedure was performed to obtain a 10 327 bp genomic DNA fragment containing seven ORFs, including a putative regulator, mpdR, and four genes, mpdC, orf1, mpdB and orf2, in the same cluster. The MpdB protein (64 kDa) was related to a flavoprotein of the glucose-methanol-choline oxidoreductase family, and the MpdC protein (55 kDa) showed a high similarity with NAD(P) aldehyde dehydrogenases. Heterologous expression of these gene products was performed in Mycobacterium smegmatis mc2 155. The recombinant strain was able to degrade an intermediate of MTBE biodegradation, 2-methyl 1,2-propanediol, to hydroxyisobutyric acid. This is believed to be the first report of the cloning and characterization of a cluster of genes specifically involved in the MTBE biodegradation pathway of M. austroafricanum IFP 2012.
Asunto(s)
Genes Bacterianos , Éteres Metílicos/metabolismo , Mycobacterium/genética , Mycobacterium/metabolismo , Proteínas Bacterianas/análisis , Proteínas Bacterianas/aislamiento & purificación , Biodegradación Ambiental , Clonación Molecular , ADN Bacteriano/química , ADN Bacteriano/genética , Electroforesis en Gel de Poliacrilamida , Flavoproteínas/genética , Regulación Bacteriana de la Expresión Génica , Glucosa/metabolismo , Hidroxibutiratos/metabolismo , Datos de Secuencia Molecular , Peso Molecular , Mycobacterium/crecimiento & desarrollo , Mycobacterium smegmatis/genética , Mycobacterium smegmatis/metabolismo , Sistemas de Lectura Abierta , Oxidorreductasas/genética , Glicoles de Propileno/metabolismo , Proteoma/análisis , Proteoma/aislamiento & purificación , Análisis de Secuencia de ADN , Análisis de Secuencia de Proteína , Homología de Secuencia de AminoácidoRESUMEN
In contaminated soils, efficiency of natural attenuation or engineered bioremediation largely depends on biodegradation capacities of the local microflorae. In the present study, the biodegradation capacities of various microflorae towards diesel oil were determined in laboratory conditions. Microflorae were collected from 9 contaminated and 10 uncontaminated soil samples and were compared to urban wastewater activated sludge. The recalcitrance of hydrocarbons in tests was characterised using both gas chromatography (GC) and comprehensive two-dimensional gas chromatography (GCxGC). The microflorae from contaminated soils were found to exhibit higher degradation capacities than those from uncontaminated soil and activated sludge. In cultures inoculated by contaminated-soil microflorae, 80% of diesel oil on an average was consumed over 4-week incubation compared to only 64% in uncontaminated soil and 60% in activated sludge cultures. As shown by GC, n-alkanes of diesel oil were totally utilised by each microflora but differentiated degradation extents were observed for cyclic and branched hydrocarbons. The enhanced degradation capacities of impacted-soil microflorae resulted probably from an adaptation to the hydrocarbon contaminants but a similar adaptation was noted in uncontaminated soils when conifer trees might have released natural hydrocarbons. GCxGC showed that a contaminated-soil microflora removed all aromatics and all branched alkanes containing less than C(15). The most recalcitrant compounds were the branched and cyclic alkanes with 15-23 atoms of carbon.
Asunto(s)
Alcanos/metabolismo , Biodegradación Ambiental , Cromatografía de Gases/métodos , Gasolina , Hidrocarburos Aromáticos/metabolismo , Microbiología del Suelo , Contaminantes del Suelo/metabolismo , Dióxido de Carbono/metabolismo , Aguas del Alcantarillado/microbiologíaRESUMEN
A new Mycobacterium austroafricanum strain, IFP 2015, growing on methyl tert-butyl ether (MTBE) as a sole carbon source was isolated from an MTBE-degrading microcosm inoculated with drain water of an MTBE-supplemented gasoline storage tank. M. austroafricanum IFP 2015 was able to grow on tert-butyl formate, tert-butyl alcohol (TBA) and alpha-hydroxyisobutyrate. 2-Methyl-1,2-propanediol was identified as the TBA oxidation product in M. austroafricanum IFP 2015 and in the previously isolated M. austroafricanum IFP 2012. M. austroafricanum IFP 2015 also degraded ethyl tert-butyl ether more rapidly than M. austroafricanum IFP 2012. Specific primers designed to monitor the presence of M. austroafricanum strains could be used as molecular tools to detect similar strains in MTBE-contaminated environment.
Asunto(s)
Agua Dulce/microbiología , Gasolina , Éteres Metílicos/metabolismo , Mycobacterium/crecimiento & desarrollo , Mycobacterium/aislamiento & purificación , Contaminantes Químicos del Agua/metabolismo , Proteínas Bacterianas/genética , Chaperonina 60 , Chaperoninas/genética , Medios de Cultivo , ADN Bacteriano/análisis , ADN Ribosómico/análisis , Agua Dulce/química , Datos de Secuencia Molecular , Mycobacterium/clasificación , Mycobacterium/genética , ARN Ribosómico 16S/genética , Análisis de Secuencia de ADNRESUMEN
The biodegradability of various types of diesel oil (DO), such as straight-run DO, light-cycle DO, hydrocracking DO, Fischer-Tropsch DO and commercial DO, was investigated in biodegradation tests performed in closed-batch systems using two microflorae. The first microflora was an activated sludge from an urban wastewater treatment plant as commonly used in biodegradability tests of commercial products and the second was a microflora from a hydrocarbon-polluted soil with possible specific capacities for hydrocarbon degradation. Kinetics of CO(2) production and extent of DO biodegradation were obtained by chromatographic procedures. Under optimised conditions, the polluted-soil microflora was found to extensively degrade all the DO types tested, the degradation efficiencies being higher than 88%. For all the DOs tested, the biodegradation capacities of the soil microflora were significantly higher than those of the activated sludge. Using both microflora, the extent of biodegradation was highly dependent upon the type of DO used, especially its hydrocarbon composition. Linear alkanes were completely degraded in each test, whereas identifiable branched alkanes such as farnesane, pristane or phytane were degraded to variable extents. Among the aromatics, substituted mono-aromatics were also variably biodegraded.
Asunto(s)
Biodegradación Ambiental , Gasolina , Cromatografía Líquida de Alta Presión , Ionización de Llama , Cinética , Aguas del Alcantarillado , Microbiología del Suelo , Contaminantes del Suelo , Eliminación de Residuos LíquidosRESUMEN
Microorganisms used in biodesulfurization of petroleum products have to withstand high concentrations of hydrocarbons. The capacities of seven desulfurizing strains of Rhodococcus to be active in the presence of solvents were evaluated. Octanol and toluene (log P=2.9) were selected as toxic solvents. The effect of the solvents was determined by measuring either inhibition of growth or the decrease in respiratory activity of the cells. Differences among strains in their resistance to solvent responses were observed, but these variations were dependent on the test used. Resistance to solvents was then compared to the capacity of the different strains to retain biodesulfurization activity in the presence of hexadecane. Inhibition of desulfurization by high concentrations of hexadecane was found to be well correlated to the sensitivity of the strains to respiration inhibition by toluene, but not to growth inhibition. This result also showed that the respirometric test was a rapid and reliable test to select solvent-resistant strains for use as resting cells in biocatalysis processes, such as biodesulfurization, in organic media.
Asunto(s)
Octanoles/toxicidad , Petróleo/microbiología , Rhodococcus/efectos de los fármacos , Compuestos de Azufre/metabolismo , Tolueno/toxicidad , Alcanos/toxicidad , Antibacterianos/toxicidad , Biodegradación Ambiental , Farmacorresistencia Bacteriana , Consumo de Oxígeno , Rhodococcus/crecimiento & desarrollo , Rhodococcus/metabolismo , Solventes/toxicidadRESUMEN
A strain that efficiently degraded methyl tert-butyl ether (MTBE) was obtained by initial selection on the recalcitrant compound tert-butyl alcohol (TBA). This strain, a gram-positive methylotrophic bacterium identified as Mycobacterium austroafricanum IFP 2012, was also able to degrade tert-amyl methyl ether and tert-amyl alcohol. Ethyl tert-butyl ether was weakly degraded. tert-Butyl formate and 2-hydroxy isobutyrate (HIBA), two intermediates in the MTBE catabolism pathway, were detected during growth on MTBE. A positive effect of Co2+ during growth of M. austroafricanum IFP 2012 on HIBA was demonstrated. The specific rate of MTBE degradation was 0.6 mmol/h/g (dry weight) of cells, and the biomass yield on MTBE was 0.44 g (dry weight) per g of MTBE. MTBE, TBA, and HIBA degradation activities were induced by MTBE and TBA, and TBA was a good inducer. Involvement of at least one monooxygenase during degradation of MTBE and TBA was shown by (i) the requirement for oxygen, (ii) the production of propylene epoxide from propylene by MTBE- or TBA- grown cells, and (iii) the inhibition of MTBE or TBA degradation and of propylene epoxide production by acetylene. No cytochrome P-450 was detected in MTBE- or TBA-grown cells. Similar protein profiles were obtained after sodium dodecyl sulfate-polyacrylamide gel electrophoresis of crude extracts from MTBE- and TBA-grown cells. Among the polypeptides induced by these substrates, two polypeptides (66 and 27 kDa) exhibited strong similarities with known oxidoreductases.