RESUMEN
The small-scale production of a severely heated factor VIII concentrate is described. As starting material for the production 48 units of fresh frozen plasma from whole-blood donations or 24 units of plasma from apheresis are used. During a glycine and sodium chloride fractionation, contaminating proteins are removed from a pooled extract of single-donor cryoprecipitates. The resulting factor VIII-rich precipitate is redissolved in freeze-drying buffer and this solution is desalted by diafiltration. After filtration, this solution is dispensed into 10 vials and frozen. The product is freeze dried, and heat treated at 80 degrees C for 72 h. The mean yield of the heat-treated product improved from 160 IU factor VIII per liter plasma at the start of the production to 215 IU per liter plasma after a modification of the purification process. The validation of the virus inactivation during freeze-drying and 80 degrees C heat treatment for 72 h showed a reduction of > or = 7.6 log PFU/ml for Sindbis and a reduction of > or = 6.4 log TCID50/ml for HIV-1. The factor VIII concentrate was clinically tested in 6 patients. It possessed a normal half-life, showed a high recovery and no side effects. A Dutch license was granted in June 1991 and since then this product has been routinely manufactured in three Dutch blood banks.
Asunto(s)
Factor VIII/aislamiento & purificación , Calor , Precipitación Química , Factor VIII/farmacocinética , Factor VIII/uso terapéutico , Liofilización , Glicina , VIH-1/fisiología , Semivida , Hemofilia A/terapia , Humanos , Concesión de Licencias , Países Bajos , Plasma , Control de Calidad , Virus Sindbis/fisiología , Replicación ViralRESUMEN
During product development of a factor VIII concentrate (Dutch blood banks) the conversion from unsterilized to autoclaved freeze-drying buffer caused impaired product characteristics after severe dry heat treatment (80 degrees C for 72 h). Analysis of the freeze-drying buffers showed the presence of fructose and glucose in heated buffers, resulting from hydrolysis of sucrose. The detrimental effect of glucose and fructose on solubility, yield of factor VIII and color of the heat-treated product was confirmed by freeze-drying and heating products spiked with increasing levels of these monosaccharides. The effect of the use of freeze-drying buffers autoclaved with and without sucrose was examined in two other factors VIII concentrates, S(8) and Z8 (Protein Fractionation Centre, Edinburgh, UK). If sucrose was present during autoclaving of the buffer, a slightly lower yield over freeze-drying and 80 degrees C heat treatment was observed. Since glucose is present as a substrate in the medium for the host cells during cultivation of viruses, its potential effect on the 80 degrees C heated product (Dutch blood banks) was examined during the validation study of the inactivation of HIV-1 and Sindbis. The cultivation cycles for the virus inocula were simulated and residual glucose levels measured. In the supernatant medium of the host cell culture used for the propagation of Sindbis no residual glucose was found. Glucose however was found in the supernatant medium of the host cell culture for propagation of HIV-1, and therefore small molecular weight substances were removed from the actual HIV-1 inoculum by ultrafiltration.(ABSTRACT TRUNCATED AT 250 WORDS)