RESUMEN
Improper disposal of animal waste is responsible for several environmental problems, causing eutrophication of lakes and rivers, nutrient overload in the soil, and the spread of pathogenic organisms. Despite the potential to cause adverse ecological damage, animal waste can be a valuable source of resources if incorporated into a circular concept. In this sense, new approaches focused on recovery and reuse as substitutes for traditional processes based on removing contaminants in animal manure have gained attention from the scientific community. Based on this, the present work reviewed the literature on the subject, performing a bibliometric and scientometric analysis of articles published in peer-reviewed journals between 1991 and 2021. Of the articles analyzed, the main issues addressed were nitrogen and phosphorus recovery, energy generation, high-value-added products, and water reuse. The energy use of livestock waste stands out since it is characterized as a consolidated solution, unlike other routes still being developed, presenting the economic barrier as the main limiting factor. Analyzing the trend of technological development through the S curve, it was possible to verify that the circular economy in the management of animal waste will enter the maturation phase as of 2036 and decline in 2056, which demonstrates opportunities for the sector's development, where animal waste can be an economic agent, promoting a cleaner and more viable product for a sustainable future.
Asunto(s)
Estiércol , Administración de Residuos , Animales , Bibliometría , Nitrógeno/metabolismo , Fósforo/metabolismo , Suelo , AguaRESUMEN
The anaerobic ammonium oxidation (anammox) process has attracted significant attention as an economic, robustness, and sustainable method for the treatment of nitrogen (N)-rich wastewater. Anammox bacteria (AnAOB) coexist with other microorganisms, and particularly with ammonia-oxidizing bacteria (AOB) and/or heterotrophic bacteria (HB), in symbiosis in favor of the substrate requirement (ammonium and nitrite) of the AnAOB being supplied by these other organisms. The dynamics of these microbial communities have a significant effect on the N-removal performance, but the corresponding metabolic pathways are still not fully understood. These processes involve many common metabolites that may act as key factors to control the symbiotic interactions between these organisms, to maximize N-removal efficiency from wastewater. Therefore, this work overviews the current state of knowledge about the metabolism of these microorganisms including key enzymes and intermediate metabolites and summarizes already reported experiences based on the employment of certain metabolites for the improvement of N-removal using anammox-based processes. PRACTITIONER POINTS: Approaches knowledge about the biochemistry and metabolic pathways involved in anammox-based processes. Some molecular tools can be used to determine enzymatic activity, serving as an optimization in nitrogen removal processes. Enzymatic evaluation allied to the physical-chemical and biomolecular analysis of the nitrogen removal processes expands the application in different effluents.
Asunto(s)
Compuestos de Amonio , Aguas Residuales , Compuestos de Amonio/metabolismo , Oxidación Anaeróbica del Amoníaco , Bacterias/metabolismo , Reactores Biológicos/microbiología , Nitrógeno/metabolismo , Oxidación-Reducción , Aguas Residuales/químicaRESUMEN
The application of the circular economy concept should utilize the cycles of nature to preserve materials, energy and nutrients for economic use. A full-scale pig farm plant was developed and validated, showing how it is possible to integrate a circular economy concept into a wastewater treatment system capable of recovering energy, nutrients and enabling water reuse. A low-cost swine wastewater treatment system consisting of several treatment modules such as solid-liquid separation, anaerobic digestion, biological nitrogen removal by nitrification/denitrification and physicochemical phosphorus removal and recovery was able to generate 1880.6 ± 1858.5 kWh d-1 of energy, remove 98.6% of nitrogen and 89.7% of phosphorus present in the swine manure. In addition, it was possible to produce enough fertilizer to fertilize 350 ha per year, considering phosphorus and potassium. In addition, the effluent after the chemical phosphorus removal can be safely used in farm cleaning processes or disposed of in water bodies. Thus, the proposed process has proven to be an environmentally superior swine waste management technology, with a positive impact on water quality and ensuring environmental sustainability in intensive swine production.
Asunto(s)
Estiércol , Fósforo , Anaerobiosis , Animales , Nitrógeno/análisis , Nutrientes , PorcinosRESUMEN
Organic carbon can affect the biological nitrogen removal process since the Anammox, heterotrophic and denitrifying bacteria have different affinities and feedback in relation to carbon/nitrogen ratio. Therefore, we reviewed the wastewater carbon concentration, its biodegradability and bioavailability to choose the appropriate nitrogen removal process between conventional (nitrification-denitrification) and Anammox-based process (i.e. integrated with the partial nitritation, nitritation, simultaneous partial nitrification and denitrification or partial-denitrification). This review will cover: (i) strategies to choose the best nitrogen removal route according to the wastewater characteristics in relation to the organic matter bioavailability and biodegradability; (ii) strategies to efficiently remove nitrogen and the remaining carbon from effluent in anammox-based process and its operating cost; (iii) an economic analysis to determine the operational costs of two-units Anammox-based process when compared with the commonly applied one-unit Anammox system (partial-nitritation-Anammox). On this review, a list of alternatives are summarized and explained for different nitrogen and biodegradable organic carbon concentrations, which are the main factors to determine the best treatment process, based on operational and economic terms. In summary, it depends on the wastewater carbon biodegradability, which implies in the wastewater treatment cost. Thus, to apply the conventional nitrification/denitrification process a CODb/N ratio higher than 3.5 is required to achieve full nitrogen removal efficiency. For an economic point of view, according to the analysis the minimum CODb/gN for successful nitrogen removal by nitrification/denitrification is 5.8 g. If ratios lower than 3.5 are applied, for successfully higher nitrogen removal rates and the economic feasibility of the treatment, Anammox-based routes can be applied to the wastewater treatment plant.
Asunto(s)
Carbono , Nitrógeno , Reactores Biológicos , Desnitrificación , Nitrificación , Oxidación-Reducción , Aguas del Alcantarillado , Aguas ResidualesRESUMEN
A collection of kinetic models to explore the bacteria pathway inhibition by high-ammonia during deammonification process was fitted. The main goal was to determine the substrate concentration to operate the deammonification with efficiency, performance and low impact to ANAMMOX and ammonia-oxidizing bacteria (AOB) by substrate. A new mathematical model was created to describe the deammonification behavior, since the empirical theoretical models showed inconsistent parameters to describe the process. The proposed model showed significant prediction to the estimable parameters and according to it, until 550 mg NH3-N L-1 no inhibitions by ammonia and nitrite were observed. However, concentrations higher than this promote the decrease on specific bacterial activity and nitrite accumulation, since it was not quickly consumed by the bacteria. The proposed model can be applied to predict microorganism affinity and inhibition by substrate over a wide range of ammonia concentrations (<900 mgNH3-N L-1) in reactors treating high-ammonia concentration swine wastewater.
Asunto(s)
Reactores Biológicos , Nitrógeno , Amoníaco , Animales , Nitritos , Oxidación-Reducción , Porcinos , Aguas ResidualesRESUMEN
The performance of a deammonification reactor fed with increasing nitrogen loading rates (NLR) was evaluated. The digestate from a continuous stirred tank reactor (CSTR) treating sludge from a swine production unit was diluted to provide different ammonia concentrations. The biomass samples from the end of each experimental phase were analyzed for microorganism community evaluation. The results proved that deammonification system supported a NLR up to 3.27 ± 0.13 g N L-1 d-1 with nitrogen removal efficiency of 83%. The specific ammonia consumption rate (µNH3-N) did not decrease up to this NLR proving the stability of reactor performance. Anammox bacteria genus shifted along the experiment and at the end the predominant anammox bacteria found in the reactor was candidatus Brocadia. Finally, it was proved that a deammonification reactor for nitrogen removal from CSTR digestate could be easily controlled only by monitoring pH and dissolved oxygen.
Asunto(s)
Nitrógeno , Aguas Residuales , Anaerobiosis , Animales , Reactores Biológicos , Oxidación-Reducción , Aguas del Alcantarillado , PorcinosRESUMEN
This work aims to evaluate the adsorption potential of bentonite and sugarcane bagasse clay for the reduction of free fatty acids in cooking oil through batch technique, experimental planning with different operating conditions (temperature, adsorbent mass and agitation). After were carried out kinetic studies and thermodynamic studies. Thus, both adsorbents were characterized by nitrogen dispersion, scanning electron microscopy with coupled energy dispersion spectroscopy. The sugarcane bagasse provided higher reductions compared to the bentonite clay, 58 and 50%, respectively. In the kinetic studies, it was observed that the pseudo-secunda model for both materials. Among the isotherms studied, the Langmuir model was better adjusted for sugarcane bagasse and Freundlich for bentonite clay. Thermodynamic parameters indicated spontaneous and endothermic adsorption at temperatures of 18°C, 20°C and 25°C. Both materials showed an advantageous result with the reduction to the adsorption of free fatty acids in the residual oil, considering that they are low-cost materials, their pre-treatment is simple from the operational point of view and their physical and chemical characteristics are favorable to the adsorption process, sugarcane bagasse contains about 42% hemicellulose, which is a hydroxyl-rich material that attracts the H+ ions from the medium.
Asunto(s)
Contaminantes Químicos del Agua , Purificación del Agua , Adsorción , Concentración de Iones de Hidrógeno , Cinética , Aceites , TermodinámicaRESUMEN
Since industrial wastes are increasing, the development of studies to find ways for their use is urgent. Waste cooking oil is an important source for the production of biodiesel, one of the main biofuels in Brazil. However, during cooking, the oil undergoes conditions that change its properties and decrease its quality, such as its acidity value. Current research treats waste cooking oil by the adsorption process using rice husk, an agro-industrial waste, and activated carbon to compare results. The potential of the adsorbents to remove free fatty acids in waste cooking oil has been investigated by the batch technique, evaluating different operating conditions of temperature, adsorbent mass and agitation. Adsorbents were characterized by nitrogen physisorption, scanning electron microscope, energy-dispersive spectroscopy and X-ray diffraction. The maximum result obtained for activated carbon at acidity reduction was 63%, using 22.4°C, 169.64â rpm and 3.39â g of adsorbent mass. Already, using the rice husk the percentage of removal was the same, 63% using 22.4°C, 80.36â rpm and 1.61â g of adsorbent, however in shorter times. The results prove that the application of the rice husk for this purpose is advantageous, for being a low-cost material, available on a large scale and that provide results similar to activated carbon.